PRL0602N ULC | Alldatasheet

Document overview

  • Manufacturer or author: Provided By ALLDATASHEET.COM(FREE DATASHEET DOWNLOAD SITE)
  • PDF pages: 4

Technical content

FEATURES: ◆ Compact 400W with 1U height Power Density: 11.11 watts/cu in ◆ Active Power Factor Corrected to EN61000-3-2 Class D ◆ Built-in Remote On-Off, Power Good, Fan Fail Alarm ◆ Peak Power 700W within 500uS Duty Duration ◆ Variable Fan Speed & Low Acoustical Noise ◆ High Quality & Reliable Component Usage ◆ Output Voltage ranging from 12 ~ 60Vdc ◆ 4 - Mechanical Options ◆ Full Range AC Input 220W ~ 400W AC-DC Active PFC SWITCHING POWER SUPPLY PRL0602N SINGLE OUTPUT SERIES PRODUCT SPECIFICATIONS: Input Voltage: 90 ~ 264Vac full range, 47 ~ 63Hz. Input Current: 8A at 90Vac full load. Inrush Current: Max. 70A@230Vac & 35A@115Vac; both under cold start conditions. Power Factor Correction: >0.9 @ Vin: 230Vac full load. Transient Response: Returns to within 1% in less than 2.5mS for a 50% load change and the peak transient does not excess 5%. Overshoot: Turn-on & off overshoot < 5% over nominal voltage. Efficiency: 75minimum (Measuring at 230V and full load). Turn On Delay: 1.5 second maximum at 120 Vac. Hold Up Time: 16mS min. at 75% of full load at 120Vac. Adjustability: Output user adjustable +/-5% minimum. Fan Drive: 12VDC/300mA offering to drive an external fan. Fan Fail (FF) Alarm: Designated as FF on pin 3 of CN1, two types of logical signal provided, contact manufacturer. Remote On-Off: Designated as INH on pin4 of CN1, requires a low signal to inhibit output. Power Supply On: Green LED designated as LED1 on the PCB. Power Good: Designated as PG on CN1 and TTL high 100-500mS after DC regulation. It goes low at least 1mS before loss of regulation. Input Fusing Protection: One T8A/250V fuse inserted in primary. Over-Power Protection: 110~140% of I-Max; Auto-recovery. Short Circuit Protection: Trip without damage and auto-recovery. Over Voltage Protection: Unit latching down when output exceed 130% and recycle AC input to reset. Over-Temperature Protection: Unit protected of excessive operating ambient 110 ℃±5 ℃, and automatic recovery. Operating Temperature: 0℃ to 70℃ ambient, de-rating at 2.5% per degree from 50℃ to 70℃. Warranty: 2 years. Switching Frequency: 68kHz PFC, 55 kHz PWM Vibration: 5 ~ 50 Hz, acceleration ±7.35 m/s*s on X,Y and Z Axis. Storage Temperature: -20℃ to 85℃. Operating Humidity: 5% to 90% RH, Non-condensing. Storage Humidity: 5% to 95% RH, Non-condensing. EMC: EN55022 class B conducted / radiated, EN61000-3-2, EN61000-3-3; EN55024 (IEC61000-4-2, IEC61000-4-3, IEC61000- 4-4, IEC61000-4-5, IEC61000-4-6, IEC61000-4-11). Safety Regulation: UL1950, CSA C22.2 No. 950-95, EN60950 and CB certificate Leakage Current: < 3.5mA @ 264Vac. (optional for 500uA max. at 240Vac / 300uA max. at 120Vac input) HI-POT Test: 1500 VAC input line to chassis (10mA AC cut off current); Isolating 3000VAC primary to secondary windings; Primary to core 1500VAC. All for 3 sec. Grounding Test: Apply 25 A from ground pin of the three prong plug to the far most earth. Max allowable resistance 0.1 ohm. Warranty: 2 years. MTBF: 100000 Hrs (according to MIL-HBK-217F) at 30 ℃ . Cooling: Internal fan is provided. Enclosure: U Type: 6(L) x 4(W) x 1.5(H) inches. C Type: 6(L) x 4(W) x 1.57(H) inches. E Type: 7(L) x 4(W) x 1.6(H) inches. F Type: 6(L) x 4(W) x 2(H)inches. Burn in: 45 +/- 5 degree C for 1 hour @230Vac with full load. Weight: Maximum weight is 800g. Copy Right Ultra Level Tech Co., Ltd 2015, All Right Reserved. Specifications subject to change without notice. E Type: 7(L) x 4(W) x 1.6(H)” F Type: 6(L) x 4(W) x 2(H)” C Type: 6(L) x 4(W) x 1.57(H)” U Type: 6(L) x 4(W) x 1.5(H)” CB ULTRA LEVEL TECH CO., LTD. We Supply the Power Customers Need ISO9001 www.ultralevel.com.tw Tel:+886-2-29180118 Fax:+886-2-29181465

OUTPUT VOLTAGE / CURRENT RATING CHART: Measured at output power connector. Note: * PRL0602N series are designated as PRL0602Nx-y where x can be U (U-Chassis), C (U-chassis with top vented cover),E (Enclosed Type with end side built-in fan) or F (Enclosed Type with top cover built-in fan) or ,y can be 12, 15, 18, 24, 28, 36, 48 or 54.

  • PRL0602NU Series: U-Chassis @400W max. with min. 26.84CFM forced airflow or 220W convection cooled output.
  • PRL0602NC Series: U-chassis with vented cover@220W max. convection cooling. * PRL0602NE Series: Enclosed with rear side built-in fan @400W max. * PRL0602NF Series: Enclosed with top built-in fan @400W max. * All output ranges are covered in agency certifications and the preset voltage will be set as standard model if any request is not preset output please contact us in advance. * Ripple and noise are measured from 10KHZ to 20MHz bandwidth at output with parallel 0.1µF ceramic and 22µF electrolytic cap acitors. * Providing peak power to 700W within 500uS for all models, longer duty duration need contact manufacture.
  • 1% minimum load is required to maintain the ripple and regulation. * Output is fully isolated. Input and Output Connector (CN2): Terminal block - Howder Part No. HD-121-7P or Molex - Mating JST VH series. Input 5 pin connector (3 pin used, pin 2 & pin 4 removed), PCB labeling: L = Line; N = Neutral; G = Chassis Ground. Output 10 pin connector. Output Pin Assignment: (See table in right). Mounting Inserts: 6 Places M4X0.7. Maximum Penetration 2mm. Logic signal connector (CN1): Mating JST XHP-4 or equivalent (CHYAO SHIUNN JS-2001-04); Mating Pins: JST SXH-002T-P0.6 FOR AWG 30 to 26. Pin 1: PG, Pin 2: RTN, PIN3: FF, Pin4: INH Fan driver connector (FAN1): 12VDC/300mA is available to drive an external fan, Mating connector JST P/N XHP-2 (2 pins 0.98 pitch), equivalent (CHYAO SHIUNN JS-2001-02). Howder Molex Pins 1 ~ 2: V+ Pins 1 ~ 5: V+ Pins 3 ~ 4: V- Pins 6 ~ 10: V- Pin 5: GND Pin 12: GND Pin 6: Neutral Pin 14: Neutral Pin 7: Line Pin 16: Line OUTLINE DRAWING: Copy Right Ultra Level Tech Co., Ltd 2015, All Right Reserved. Specifications subject to change without notice. Model Output Range Preset Voltage Max. Output Current Regulation Ripple & Noise Type U & E & F (forced air) Type U & C (Convection) PRL0602Nx-12 10 ~ 13.8V 12 V 33.33A 18.33A +/- 1% 1% PRL0602Nx-15 14 ~ 15.5V 15 V 26.67A 14.67A +/- 1% 1% PRL0602Nx-18 16 ~ 20V 18V 22.22A 12.22A +/- 1% 1% PRL0602Nx-24 21 ~ 26V 24V 16.67A 9.17A +/- 1% 1% PRL0602Nx-28 27 ~ 34V 28V 14.29A 7.86A +/- 1% 1% PRL0602Nx-36 35 ~ 42V 36V 11.11A 6.11A +/- 1% 1% PRL0602Nx-48 43 ~ 50V 48V 8.33A 4.58A +/- 1% 1% PRL0602Nx-54 51 ~ 60V 54V 7.41A 4.07A +/- 1% 1% ULTRA LEVEL TECH CO., LTD. We Supply the Power Customers Need ISO9001 www.ultralevel.com.tw Tel:+886-2-29180118 Fax:+886-2-29181465

Copy Right Ultra Level Tech Co., Ltd 2015, All Right Reserved. Specifications subject to change without notice. PRL0602NC Series (U chassis with Top vented cover): 6(L) x 4(W) x 1.57(H) inches; Weight: 650g. ULTRA LEVEL TECH CO., LTD. We Supply the Power Customers Need ISO9001 www.ultralevel.com.tw Tel:+886-2-29180118 Fax:+886-2-29181465 PRL0602NU Series (U-Chassis Type only): 6(L) x 4(W) x 1.5(H) inches; Weight: 600g.

ULTRA LEVEL TECH CO., LTD. We Supply the Power Customers Need ISO9001 www.ultralevel.com.tw Tel:+886-2-29180118 Fax:+886-2-29181465 Copy Right Ultra Level Tech Co., Ltd 2015, All Right Reserved. Specifications subject to change without notice. PRL0602NE Series (Enclosed with Rear Side built-in Fan Type): 7(L) x 4(W) x 1.6(H)inches; Weight: 750g. PRL0602NF Series (Enclosed with Top built-in Fan Type): 6(L) x 4(W) x 2(H)inches; Weight: 800g.