A6625365

40PW03G TOSHIBA | Alldatasheet

Document overview

• Manufacturer or author: Toshiba Corporation
• PDF pages: 126

Technical content

1-1, SHIBAURA 1-CHOME, MINATO-KU, TOKYO 105-8001, JAPAN PRINTED IN U.K Feb., 2000 UK FILE NO. 030-200001 SERVICE MANUAL COLOUR TELEVISION C9PJ Chassis 40PW03G,40PW03B

– 2 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS TABLE OF CONTENTS CHAPTER 1 GENERAL ADJUSTMENTS CHAPTER 2 SPECIFIC INFORMATIONS APPENDIX: CIRCUIT DIAGRAM

– 3 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS CHAPTER 1 GENERAL ADJUSTMENTS SAFETY INSTRUCTIONS WARNING : BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION PRECAUTION”, “SAFETY PRECAU- TION” AND “PRODUCT SAFETY NOTICE” INSTRUCTIONS BELOW. X-RAY RADIATION PRECAUTION 1. Excessive high voltage can produce potentially hazard- ous X-RAY RADIATION. To avoid such hazards, the high voltage must not be above the specified limit. The nominal value of the high voltage of this receiver is (A) kV at zero beam current (minimum brightness) under a (C) V AC power source. The high voltage must not, under any circum- stances, exceed (B) kV . Refer to table-1 for high voltage (A), (B) & AC voltage (C). (See SETTING & ADJUSTING DATA on page 34) Each time a receiver requires servicing, the high voltage should be checked following the HIGH VOLTAGE CHECK procedure in this manual. It is recommended that the read- ing of the high voltage be recorded as a part of the service record. It is important to use an accurate and reliable high voltage meter. 2. The only source of X-RAY RADIATION in this TV receiver is the picture tube. For continued X-RAY RADIATION pro- tection, the replacement tube must be exactly the same type tube as specified in the parts list. 3. Some part in this receiver have special safety-related char- acteristics for X-RAY RADIATION protection. For contin- ued safety, parts replacement should be undertaken only after referring to the PRODUCT SAFETY NOTICE below. SAFETY PRECAUTION WARNING : Service should not be attempted by anyone unfamiliar with the necessary precautions on this receiver. The following are the necessary precautions to be observed before servicing this chassis. 1. An isolation transformer should be connected in the power line between the receiver and the AC line before any service is performed on the receiver. 2. Always discharge the picture tube anode to the CRT conductive coating before handling the picture tube. The picture tube is highly evacuated and if broken, glass fragments will be violently expelled. Use shatter proof goggles and keep picture tube away from the unprotected body while handling. 3. When replacing a chassis in the cabinet, always be certain that all the protective devices are put back in place, such as; non- metallic control knobs, insulating covers, shields, isolation resistor-capacitor network etc. PRODUCT SAFETY NOTICE Many electrical and mechanical parts in this chassis have special safety-related characteristics. These characteristics are often passed unnoticed by a visual inspection and the protection afforded by them cannot necessarily be obtained by using replacement components rated for higher voltage, wattage, etc. Replacement parts which have these special safety char- acteristics are identified in this manual and its supplements; electrical components having such features are identified by the international hazard symbols on the schematic diagram and the parts list. Before replacing any of these components, read the parts list in this manual carefully. The use of substitute replacement parts which do not have the same safety characteristics as specified in the parts list may create shock, fire, X-ray radiation or other hazards.

– 4 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS CRT ASSEMBLY REPLACEMENT AND MOUNTING CAUTION : DO NOT LOOSEN THE HEX HEAD BOLTS WITH SPRINGS (12 PCS), BECAUSE THOSE ARE FOR SEALING OF CRT COOLANT. Lens and Neck Components View Attention Serviceman The Hex Head Bolts with Springs. (see sketch) used on CRT assembly, are “NOT” Adjustment Screws DO NOT LOOSEN-FLUID LEAKAGE WILL OCCUR. 8 o’clock 4 o’clock

4 Screws

S.V.M. Coil CRT DRIVE Board Lens Assembly CRT Assembly Deflection Y oke and Conver Y oke CRT Mounting

– 5 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS TO REMOVE CRT (Same procedure for R, G, B) 1. Remove CRT DRIVE Board, S. V . M. COIL and DEF . YOKE from CRT. 2. Remove Lens Assembly. 3. Detach CRT Anode Cap from CRT. 4. Remove CRT Assembly from CRT Mounting. CRT REPLACEMENT (Same procedure for R, G, B) Reverse the removal procedures except the followings. 1. Anode Cable should be replaced with new one. See "SERVICING PRECAUTIONS" shown below. 2. Install silicon (T461B) to the CRT, replace the Anode cable and put enough silicon again on around the An- ode Cap as illustrated. CAUTION: Align the Anode cable as illustrated on page ADJUSTING PROCEDURE IN REPLACING CRT 3. PICTURE TILT ADJUSTMENT (page 7.) 4. USER CONVERGENCE CENTER CHECK (Refer to owner's manual.) 5. CENTERING ADJUSTMENT (page 7.) 6. CONVERGENCE ADJUSTMENT (page 23.) 7. WHITE BALANCE ADJUSTMENT (page 15.) Adjustments are complete. SERVICING PRECAUTIONS n Check the point of anode lead in a straight line, if it is winding, please revise it. Anode lead holder n Do not use a magnetized screw driver for screws of Deflection Y oke and Velocity Modulation Coil to avoid magnetization of electron gun. Magnetization of electron gun will degrade basic function and result in unbalance of right and left shift of user static convergence, and result in no variable quantity. n When replacing the anode cap assembly (CRT) or anode lead assembly (F .B.T.), remove the anode lead holder from old one and attach the holder again to new anode lead. Screw for D.Y Screw for SVM coil Silicon (On shaded area) TSE3843W #23960136 2 ~ 5 mm 15 ~ 25 mm Anode Cap

– 6 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS WARNING : BEFORE SERVICING THIS CHASSIS, READ THE "X-RAY RADIATION PRECAUTION", "SAFETY PRE- CAUTION" AND "PRODUCT SAFETY NOTICE" ON PAGE 3 OF THIS MANUAL. PICTURE TUBE COMPONENTS ADJUSTMENT ADJUSTING PROCEDURE IN REPLACING CRT User convergence center check Lens focus Electrical focus Cutoff Centering (PAL) Convergence adjustment (PAL/NTSC) Y oke horizontal End Sub bright adjustment White balance DESCRIPTION OF NECK COMPONENTS 1 Deflection yoke and convergence yoke. The position on the neck is required most front (CRT fun- nel side) and the screw is fastened after rotating yoke adjusting picture tilt.

2 Centering magnet

After adjusting picture tilt, picture position is finally fixed by this magnet. In order to get maximum margin of user convergence con- trol for center of screen, this magnet have to be used for center convergence adjustment. PREPARATION Operate the receiver for at least 5 minutes. R, G, B CUTOFF (SCREEN VR) ADJUSTMENT 1. Adjust before replace the screen assembly. 2. Set user control to reset position. ( CONTRAST → Max BRIGHTNESS, COLOR, TINT → Center.) 3. Call up the adjustment mode display, then select the item RCUT. 4. Adjust the data of items RCUT , GCUT , and BCUT to "40H". 5. Press the -/-- button on Remote. (Y -MUTE : ON) 6. Gradually rotate R, G and B screen volume of FOCUS PAC clockwise or counterclockwise until the raster appears slightly on the CRT through the each lens, and leave them. (Lookin to the lens in order to check the raster.) 7. Press the -/-- button on Remote. (Return to Normal Picture) S.V.M. COIL RGB FOCUS ADJUSTMENT 1. Call-up the adjustment mode (see page 10) 2. Press a button on the remote controller in order to display the internally-generated cross-hatch (See TEST SIGNAL SELECTION on page 11.) 3. Expose only RED by covering the GREEN and BLUE lenses with caps. 4. Loosen the RED lens fixing screws (refer to Fig. a), and adjust the RED lens focus to obtain the sharpest point while observing the middle and peripheral sections of the screen. Fig. a 5. Use the focus VR of “R” of the focus pack in order to adjust the electric focus in the middle and peripheral sections of the screen to its sharpest level. 6. Check the RED focus of the whole screen and if necessary repeat steps 4 and 5. 7. Fix the RED lens by tightening its fixing screws. 8. Expose only GREEN by covering the RED and BLUE lenses with caps. 9. Display the internally-generated cross-hatch signal. 10. Adjust the GREEN lens focus on the left border of the screen to its sharpest level, then check the focus on the right border, and if it is at its sharpest level, fix it in that position by tightening the lens screws. (1) If the horizontal line toward the right border is red- flared, turn the lens screw slightly right in order to balance it with the left border. (After adjustment, the left border tends to be slightly green-flared, and the right border tends to be slightly red-flared.) (2) If the horizontal line toward the right border is green- flared, turn the lens screw slightly left in order to balance it with the left border. (After adjustment, the left border tends to be slightly red-flared, and the right border tends to be slightly green-flared.) Note:The aim of the above-described adjustment procedure for the Green lens focus is to obtain the best lens focus after 2 - 3 hours of warming up taking into account the focus drift; it applies if the warming up time before the adjustment is less than 30 minutes. (The horizontal line in the screen middle section tends to be slightly red- flared.)

– 7 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS In case of warming up of more than 2 hours under a condition that the large anode current is running through the projection tube so that for example the all-white pattern appears, adjust to obtain the sharpest focus while observing the whole screen like in the RED case. 11. Press a button on the remote controller in order to display the internally-generated black cross-hatch. (See TEST SIGNAL SELECTION on page 11.) 12. Use the focus VR of “G” of the focus pack in order to ad- just the electric focus in the middle section of the screen to its sharpest level. Note: Normally the most clearly visible point of the scanning line is the sharpest point of the Green focus, however as the characteristics vary depending on the projection tube, the sharpest focus points of the vertical and horizontal lines may not match each other, thus when you turn the focus VR, if the picture tends to be tremendously unstable (rolls horizontally or vertically), adjust the balance of the vertical and horizontal lines to its best position. 13. Check the GREEN focus of the whole screen and if necessary repeat steps 10 and 11. 14. Fix the GREEN lens by tightening up its fixing screws. 15. Expose only BLUE by covering the RED and GREEN lenses with caps. 16. Press a button on the remote controller in order to display the internally-generated cross-hatch (See TEST SIGNAL SELECTION on page 11.) 17. Loosen the BLUE lens fixing screws (refer to Fig. a), and adjust the BLUE lens focus while observing the middle and peripheral screen sections. 18. Press a button on the remote controller in order to display the internally-generated black cross-hatch (See TEST SIG- NAL SELECTION on page 11.) 19. Use the focus VR of “B” of the focus pack in order to adjust the focus in the middle section of the screen to its sharpest level. (The point of the Blue focus becomes sharpest when the brightness level of BLUE is lowest, the cross-hatch is clearly visible.) TILT ADJUSTMENT Rotate R, G, B deflection yoke so that picture becomes hori- zon, then fasten screw. CENTERING ADJUSTMENT 1. Stretch a thread between two center slots of screen edge (top and bottom, left and right). 2. Select the adjustment mode. (See page 10.) 3. Press TV/VIDEO button on the Remote Control to display the black cross-hatch. 4. Adjust G centering magnet so that the cross-hatch pat- tern center comes to screen center. 5. Perform HEIGHT adjustment . (See page 14.) 6. Perform WIDTH adjustment. (See page 14.) 7. Check whole quality of green line. 8. Adjust R, B centering magnet so that the cross-hatch pat- tern center comes to screen center. Note: Keep in mind that only the BLUE electric focus is ad- justed with the black cross-hatch. 20. Check the BLUE focus of the whole screen and if neces- sary repeat steps 17 and 19. 21. Fix the BLUE lens by tightening its fixing screws.

– 8 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS LOCATION OF SCREEN AND FOCUS VR'S To remove the Speaker grille and Front panel. SCREEN VR Front panel Speaker grille FOCUS VR RGB REPLACEMENT OF HIGH VOLTAGE CABLE ANODE LEAD RUBBER BOOT LEAD HOLDER Z450 TPA5007 Fig. a 1. When replacing Anode Lead or Anode Cap with new one, remove Lead Holder from old lead as shown in figure below, and put it on new lead. Do not throw away Lead Holder. NOTE : THE LEAD HOLDER IS ATTACHED TO TPA5007 (Z450), BUT IS NOT ATTACHED TO ANODE LEAD AND ANODE CAP. RUBBER BOOT IS ATTACHED TO ANODE LEAD AND ANODE CAP. 2. Detaching Lead Holder RUBBER BOOT OLD ANODE LEAD or ANODE CAP LOCK LEAD HOLDER Cut here rubber boot and lead together to detach Lead Holder. Fig. b

– 9 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS WARNING : BEFORE SERVICING THIS CHASSIS, READ THE "X-RAY RADIATION PRECAUTION", "SAFETY PRECAU- TION" AND "PRODUCT SAFETY NOTICE" ON PAGE 3 OF THIS MANUAL. SERVICE POSITION In order to assure the performance, processed wires shall be replaced after the repair work. Work procedures are as follows: 1. Remove the back board. 2. Remove lead wires. 3. Draw out the chassis. 4. Rest the chassis against the back cabinet, chassis as shown bellow. After repair work finished, replace it in the opposite procedure.

– 10 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS SERVICE MODE 1. ENTERING TO SERVICE MODE S (Service mode display) Item Data or Sound Mute 3) While pressing the o button, press MENU button on TV set. 2) Press o button again to keep pressing. 2. DISPLAYING THE ADJUSTMENT MENU 1) Press MENU button on TV. 3. KEY FUNCTION IN THE SERVICE MODE The following key entry during display of adjustment menu provides special functions. Screen adjustment mode ON/OFF: -/-- button (on Remote) Test signal selection : a button (on Remote) Selection of the adjustment items : Channel s/t (on TV or Remote) Change of the data value : Volume ; +/– (on TV or Remote) Adjustment menu mode ON/OFF : MENU button (on TV) Initialization of the memory (QA02) : CALL + Channel button on TV (s) Reset the count of operating protect circuit to “00”: CALL + Channel button on TV ( t) “RCUT” selection : 1 button “GCUT” selection : 2 button “BCUT” selection : 3 button “SCNT” (or “CNTX”) selection : 4 button “COLC” (or “SCOL ”) selection : 5 button “TNTC” selection : 6 button Convergence adj : YELLOW button Self diagnostic display ON/OFF : 9 button 1) Press o button once on Remote Control. Adjustment mode Press Press Service mode Item DataS Color thickness correction note: Displayed differently as shown below, de- pending on the setting of the receiving color system. COLP (PAL) COLC (NTSC) COLS (SECAM) CAUTION : Never try to perform initialization unless you have changed the memory IC.

– 11 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS 4. SELECTING THE ADJUSTING ITEMS 1) Every pressing of CHANNEL s button in the service mode changes the adjustment items in the order of table-2. (t button for reverse order) Refer to table-2 for preset data of adjustment mode. (See SETTING & ADJUSTING DATA on page 34) 5. ADJUSTING THE DATA 1) Pressing of VOLUME ; +/– button will change the value of data in the range from 00H to FFH. The variable range depends on the adjusting item. 6. EXIT FROM SERVICE MODE 1) Pressing POWER button to turn off the TV once. n INITIALIZATION OF MEMORY DATA OF QA02 After replacing QA02, the following initialization is required. 1. Enter the service mode, then select any register item. 2. Press and hold the CALL button on the Remote, then press the CHANNEL s button on the TV. The initialization of QA02 has been complated. 3. Check the picture carefully. If necessary, adjust any adjustment item above. Perform “Auto search Memory” on the owner’s manual. CAUTION: Never attempt to initialize the data unless QA02 has been replaced. 7. TEST SIGNAL SELECTION 1) Every pressing of a button on the Remote Control changes the built-in test patterns on screen as described below in SERVICE MODE. Signals Picture

• Red raster
• Green raster
• Blue raster
• All White
• Black cross-hatch * The signals marked with are not usable to display in the Test signal for some model. Signal off NTSC signals (5 patterns) PAL signals (5 patterns)

– 12 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS 8. SELF DIAGNOSTIC FUNCTION 1) Press “9” button on Remote Control during display of adjustment menu in the service mode. The diagnosis will begin to check if interface among IC’s are executed properly. 2) During diagnosis, the following displays are shown. 2300****/CR POWER : 00/CR /CR BUS CONT : OK/CR BLOCK : UV V1 V2 V3/CR QV01 /CR /CR <SELF CHECK>

1 Part number of microcomputer (QA01)

2 Operation number of protecting circuit ----“00” is nor-

mal. When indication is other than “00”, overcurrent apts to flow, and circuit parts may possibly be damaged. 3 BUS CONT ----“OK” is normal. When indication shows “Q uuu (Green: OK, Red: NG)”, the device with the number may possibly be dam- aged.

4 BLOCK

UV : TV reception mode V1 : VIDEO 1 input mode (a1) V2 : VIDEO 2 input mode (a2) V3 : VIDEO 3 input mode (a3) Indicated color of mode now selected : Green and Red Indicated color of other modes : White Green :Normal Red : The microcomputer operates to provide judgement of no video signal. The red color is still indicated though the signal is input, failure may exist in input signal line including QV01. QV01 : In case of indication green ---Normal In case of indication red with input signal---- Failure may exist in output line including QV01. NOTE: Component which controls character display on screen is QT01 (TELETEXT IC.). If this display function fails to operate due to damage in QT01, self diagnosis procedure is as follows. (1) In case that on timer indicator is blinking with interval of 0.5 seconds; it means protecting cir- cuit (Current limiter) is operating, and circuit components may possibly be damaged. Check related components. * The items marked with are not usable to display in the SELF DIAGNOSTIC FUCTION for some model.

– 13 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS DESIGN MODE 1. ENTERING TO DESIGN MODE ITEM DATA S D Press (Design mode) (Adjustment mode) Press 3) Press MENU button on TV.2) While pressing CALL button on Remote and press MENU button on TV. 1) Select the Service mode. When QA02 is initialized, items “OPT0” and “OPT1” of DESIGN MODE are set to the data of the representative model of this chassis family. Therefore, because ON-SCREEN specification remains in the state of the representative of model. This model is required to reset the data of items “OPT0” and “OPT1”. 2. SELECTING THE ADJUSTING ITEMS Every pressing of CHANNEL t button in the design mode changes the adjustment items in the order of table-3. (s button for reverse order) Refer to table-3 for data of design mode. (See SETTING & ADJUSTING DATA on page 34) 3. ADJUSTING THE DATA Pressing of VOLUME s or t button will change the value of data.

– 14 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS ELECTRICAL ADJUSTMENT ITEM ADJUSTMENT PROCEDURE 1. Select picture size WIDE mode. 2. Call up the adjustment mode display, and press the TV/VIDEO button on the remote untill the white cross dot pattern appears on the screen. 3. Press the CHANNEL s or t button to select the item WID and press the VOLUME s or t button to get the pictuer so the left and right edges of rester begin to lack. 4. Press the VOLUME s or t to advance the data 22 steps. * CAUTION "WID " data don't adjust other picture size, only WIDE mode. WIDTH (WID) PAL 1. Call up the adjustment mode display, then select the item HIT. 2. Press the VOLUME s or t button to get the picture so the top of raster begins to lack. 3. Press the VOLUME s button to advance the data by following steps. WIDE: 7 steps Super Live: 11 steps CINEMA: 10 steps * CAUTION First adjust WIDE mode next other. Note : Check the vertical picture position is correct. HEIGHT (HIT) WIDTH (NWID) 1. Select picuter size wide mode. 2. Call up the adjustment mode display, and press the TV/VIDEO button on the remote untill the white cross dot pattern appears on the screen. 3. Press the CHANNEL s or t button to select the item WID and press the VOLUME s or t button to get the pictuer so the left and right edges of rester begin to lack. 4. Press the VOLUME s or t to advance the data 16 steps. 5. Change picture size Super Live and CINEMA adjust "NWID" data same value for WIDE mode. NTSC HEIGHT (NHIT) 1. Call up the adjustment mode display, then select the item HIT. 2. Press the VOLUME s or t button to get the picture so the top of raster begins to lack. 3. Press the VOLUME s button to advance the data by following steps. WIDE: 7 steps Super Live: 13 steps CINEMA: 10 steps Note : Check the vertical picture position is correct.

– 15 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS ITEM ADJUSTMENT PROCEDURE WHITE BALANCE (RCUT) (GCUT) (BCUT) (RDRV) (BDRV) Black and White pattern 1. Set user control to reset position. ( CONTRAST → Min. BRIGHTNESS, COLOR, TINT → Center.) 2. Call up the adjustment mode display, then select the item RCUT. 3. Adjust the data of items RCUT , GCUT , and BCUT to "40H". 4. Press the a button on PJTV. (Y -MUTE : ON) 5. Gradually rotate R, G and B screen volume of FOCUS PAC clockwise or counterclockwise until the raster appears slightly on the CRT through the each lens, and leave them. (Lookin to the lens in order to check the raster.) 6. Press the a button on PJTV. (Return to Normal Picture) 7. Press the a button on Remote, and select the Black and White pattern. 8. Adjust the data of items RCUT , GCUT and BCUT for proper white-balanced picture in low light area. 9. Adjust the data of items RDRV and BDRV for proper white-balanced picture in high light area. 10. Check the white balance in both low and high light areas. If necessary, perform again steps from 8 to 9. High light area Adjust "RDRV" or "BDRV" to be white. Low light area Fine adjust "RCUT", "GCUT" or "BCUT" to be black.

– 16 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Item Name Setting Input signal Measuring point Adjusting method Adjustment standard [SCNT] [BRTC] [COLP] [BELL] [COLS] [SRY] [SBY] Sub-contrast Sub-bright center Sub-color center PAL BELL filter Sub-color center SECAM SECAM R-Y black level SECAN B-Y black level Dynamic mode Audio system: I Dynamic mode Dynamic mode Dynamic mode Dynamic mode Dynamic mode Sub-bright signal (PAL-I signal) Sub-bright signal Sub-bright signal (PAL) SECAM color bar SECAM color bar SECAM color bar SECAM color bar TP46B SIGNAL unit Screen adjustment TP46B SIGNAL unit TPM01 SIGNAL unit TP46B SIGNAL unit TP02 SIGNAL unit TP01 SIGNAL unit y Adjust the amplitude from the pedestal level to the white peak. y Adjust the number of collapsed black lines of the sub-bright signal. x Carry out adjustment after adjusting the W/B and SCNT. y Adjust the amplitude of the color bar. x Adjust the P-P value of the upper half. y Use a synchroscope and adjust so that the waveforms can become flat. x Adjust at the white part. y Adjust the amplitude of the color bar. (Apply SCREEN mute during adjust- ment) x Adjust the P-P value of the upper half. y Adjust so that the level of the mono- chrome signal part can meet the level of the H.BLK. x Carry out adjustment after adjusting the BELL. y Adjust so that the level of the mono- chrome signal part can meet the level of the H.BLK. x Carry out adjustment after adjusting the BELL. 2.4 ± 0.1 Vpp 4 ± 1.5 linee 1.30 ± 0.1 Vpp 100 ± 10 % 1.95 ± 0.1Vop 0 ± 10 mV 0 ± 10 mV (Reference factory adjustment)

– 17 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Item Name Setting Input signal Measuring point Adjusting method Adjustment standard Screen adjustment Focus adjustment RDRV BDRV RCUT BCUT High voltage adjustment Screen Focus Bright part W/B Dark part W/B High voltage Factory- screen- adjustment mode Dynamic mode Cinema mode Dynamic mode Retoma signal (PAL-I) Phillips pattern (PAL-I) CRT screen Crosshatch signal Screen adjustment Screen adjustment Screen adjustment Between T461 and Z450 y Make the surrounding as dark as possible. x Enter factory-screen-adjustment mode. (Y mute, DRV .CUT. = 40 H) c Directly observe the CRT screen, and adjust the screen VR to the point where it begins to emit light. v Use R, G, and B tubes respectively to perform above-mentioned adjustments. y Make adjustments to achieve the best possible position by repeating electrical and optical focusing. x Use jigs to protect the CRTs, except the axis under adjustment, from any light. c Use R, G, ad B tubes respectively to perform above-mentioned adjustments. y Adjust the color temperature of the bright part (103cd/m 2). y Adjust the color temperature of the dark part (17cd/m2). y Connect a voltmeter between T461 and Z450 and adjust the high voltage with R450. (User adjustment standard) Point where it begins to emit light. For details, refer to the focus adjust- ment method introduced in the next page. 8750k–0.002uv 8750k–0.002uv 30.7 ± 0.2kV

– 18 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Model Adjustment points Adjustment methods 40PW03G 40PW03B Electrical focus Lens focus (Precautions) Conditions: (1) RED, BLUE: Internal Retoma signals (PAL) (2) GREEN: Internal crosshatch signal (white crosshatch on black background) (3) User adjustment: Dynamic mode, cinema mode (4) Carry out electrical focus and lens focus after rough adjustment. (5) Use the jig to protect everything, except the color subjected to adjustment, from exposure to light. (1)Receive the internal Retoma signals, use the focus VR of the focus pack (Z410), and adjust the electrical focus of each R and B projection tube to the position where the center of the screen gets optimally focused. (2)Receive the internal crosshatch signals, use the focus VR of the focus pack (Z410), and adjust the electrical focus of G so that the vertical scanning lines on the screen center can appear most clearly. (1)R, B: Receive the internal Retoma signals, watch the screen center and its periphery, and make adjustment to the best possible focus. (2)G: Adjust this by the method introduced in the next page. y Carry out anticipated adjustment on the G lens, considering the time until the lens focus stabilizes. x The level of anticipated adjustment on the G lens results in a required level of correction, if an adjustment point is set on the screen. c During a heat run, be sure to keep lower the G’s screen VR of the focus pack from turning on the power of the set until immediately before the cutoff adjustment in order to stabilize the G’s coupling liquid temperature. Focus adjustment method (1/2)

– 19 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Model Metodo di regolazione [1] 40PW03 series (1)Receive internal crosshatch signals, use the lens cap, and concentrate on the single color of G. (2)Watch the horizon of both the left and right ends on the horizontal axis of the screen, adjust the lens focus of G to the very best, and check that the left-and-right focus balance is appropriate. (Check left-and right balance of G lens focus) y Use the left (or right) end crosshatch and make the best adjustment on the G’s lens focus. x Check the right (or left) end focus. (3)If the left and right lens focus is not properly balanced (tendency for flare), divide and adjust it to the middle grade. (4)Check on the periphery, and make certain that the focus grade lies within a tolerable level (including flare). Focus adjustment method (2/2) GREEN lens focus adjustment Adjusting points Screen Left end Right end ø 100 mm ø 100 mm (Point of observation) Inside the circle of 100mm that is in contact with left and right bezels.

– 20 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Item Name Setting Input signal Measuring point Adjusting method Adjustment standard Screen position adjustment HIT VLIN HIT VLIN HIT VLIN Vertical ampli- tude adjustment (PAL WIDE) Vertical ampli- tude adjustment (PAL Super-live) Vertical ampli- tude adjustment (PAL cinema) Dynamic mode Dynamic mode WIDE mode Dynamic mode Super-live mode Dynamic mode CINEMA mode Phillips pattern (PAL-I) Phillips pattern (PAL-I) Phillips pattern (PAL-I) Phillips pattern (PAL-I) Screen adjustment Screen adjustment Screen adjustment Screen adjustment (1)Adjust the vertical and horizontal screen positions and centering magnet so that the central + mark of the dummy screen and the + mark of the Phillips pattern can overlap in conformity. Carry this out individually on 3 tubes of R, G, and B (Note) Do not move HPOS, VPOS data (1)Turn the screen size to WIDE. (2)In the first place, shorten the vertical amplitude using HIT data until the upper and low flags emerge on the screen. (3)Then, extend the vertical amplitude with the HIT data until either upper or lower flag end conforms to the screen end (Adjust the vertical center of the pattern to the central mark of the screen.) (1)Turn the screen size to Super-live. (2)Adjust with the HIT so that the top and bottom of the inner circle of Phillips pattern will contact the screen edge. (Note) VLIN adjustment is not performed. (1)Turn the screen size to CINEMA. (2)Adjust the registers on the top and bottom of the Phillips pattern as shown in the next page. (Note) Do not touch the centering magnet Less than ø7mm Upper and lower flags are to be in contact The inner circle is to contact the screen edge Completion of adjustment

– 21 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Item Name Setting Input signal Measuring point Adjusting method Adjustment standard HIT VLIN WID NHIT NLIN NHIT NHIT NLIN NHIT NLIN Vertical ampli- tude adjustment (PAL SUB- TITLE) Vertical ampli- tude adjustment PAL WIDE Vertical ampli- tude adjustment NTSC WIDE Vertical ampli- tude adjustment SUPER-LIVE NTSC Vertical ampli- tude adjustment CINEMA NTSC Vertical ampli- tude adjustment SUB-TITLE NTSC Dynamic mode SUB- TITLE mode Dynamic mode WIDE mode Dynamic mode WIDE mode Dynamic mode SUPER-LIVE mode Dynamic mode CINEMA mode Dynamic mode SUB-TITLE mode Phillips pattern (PAL-I) Phillips pattern (PAL-I) Monosco signals NTSC LEADERE-435B Monosco signals NTSC LEADER-435B Monosco signals NTSC LEADER-435B Monosco signals NTSC LEADER-435B Screen adjustment Screen adjustment Screen adjustment Screen adjustment Screen adjustment Screen adjustment (1)Turn the screen size to SUB-TITLE. (2)Adjust the registers on the top and bottom of the Phillips pattern as shown in the next page. (Note) Do not touch the centering magnet (1)Turn the screen size to WIDE. (2)The left and right flags of the Phillips pattern are to contact the screen edge. (3)The user center position adjustment is to be 0. (1)Turn the screen size to WIDE mode. (2)The 1st line on the screen is to be hidden by the mask. (1)Turn the screen size to SUPER-LIVE mode. (2)Adjust so that the upper side 3rd line on the screen will contact the screen edge. (3)Do not adjust the NVLI. (1)Turn the screen size to CINEMA mode. (2)Adjust so that the character 30 on the upper, lower, and left-and-right ends will contact the screen edge. (1)Turn the screen size to SUB-TITLE mode. (2)Adjust so that the upper side 5th line of the register on the screen will contact the screen. (3)The NVLI is not to be adjusted. Completion of adjustment

– 22 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Item Name Setting Input signal Measuring point Adjusting method Adjustment standard NWIDE Horizontal amplitude adjustment WIDE NTSC Dynamic mode WIDE mode Monosco signals NTSC LEADER-435B Screen adjustment (1)Turn the screen size to WIDE. (2)Adjust the 2nd left register to the left edge of the screen. (3)When you change the NWID value on the WIDE screen also input the identical data to SUPER-LIVE and CINEMA. Completion of adjustment Item Name Setting Input signal Measuring point Adjusting method Adjustment standard PLL Frequency adjustment Q709 Emitter (1)Apply +5V to #15, #16 terminals +9V to #13 terminal –9V to #14 terminal. (2)Adjust emitter’s frequency to Q709 with L719. Unit adjustment DIGITAL-CONVER 32 ± 0.1 MHz

– 23 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS CONVERGENCE ADJUSTMENT 1. Screen Adjustment The four PAL screens Wide/4:3, Super Live, Cinema and Subtitle, and the four NTSC screens Wide/4:3, Super Live, Cinema and Subtitle are adjusted. When adjusting, input an external signal for matching the sync. CAUTION: The convergence circuit eliminates screen distortion but cannot make large corrections such as changing the overall screen size. Use caution because the protection circuit will be activated if corrections are excessively large. Before starting to adjust the various screens, always adjust the vertical size (HIT) and horizontal size (WID) by changing the main deflection data. Execute the adjustment screens in the sequence Wide/4:3 → Super Live → Cinema → Subtitle for both PAL and NTSC. 1-1. Entering Adjustmet Menu S + + MENU key F+Yellow key Menu screen Adjusting screen CONVER ADJUST MENU CALL: to exit +Adjust PAL Wide PAL Wide to Others Adjust PAL S.Live Adjust PAL Cinema Adjust PAL S.title PAL to NTSC (Wide) PAL to NTSC (ALL) Adjust NTSC Wide NTSC Wide to Others Adjust NTSC S.Live Adjust NTSC Cinema Adjust S.title or MENU SELECTION + key + keySCREEN ADJUSTMENT Service data indication

– 24 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS sole menu key to enter the service mode. the convergence menu. cY ellow or 7 key .. Convergence menu key. change-over. colour selection). menu. 1-2. Remote Control Key Fig. 2 CH F f v ? ^ yX SIZE V TEXT CALL MENU EXIT REC VTR/DVD ENTER SELECT -/-- Çi 4 5 6 7 8 9 0 a P b h i g j n o p k c a m l

– 25 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS ItemNO Description 1 Adjust PAL Wide Used for manual adjustment of the Wide/4:3 screen in the P AL mode. Returns to the original screen data screen before data conversion, explained below.

2 PAL Wide to others Automatically saves approximate supplementary data for the other PAL screens based

on the PAL Wide/4:3 screen data. First, the PAL Wide/4:3 screen data are converted to Super Live and the values are saved. Next, the data are converted to Cinema and the values are saved. Finally, the data are converted to Subtitle and the values are saved, and then the operation ends. Manually check the other screen modes as described below and make corrections if distortion, etc., is present. Please be aware that all PAL screens are re-adjusted when this menu is selected and executed. 3 Adjust PAL S.Live Used for manual adjustment of the PAL Super Live screen. Select this mode for Super Live screen color matching and distortion adjustment. Use the specified dimensions when adjusting. 4 Adjust PAL Cinema Used for manual adjustment of the PAL Cinema screen. Select this mode for Cinema screen color matching and distortion adjustment. Use the specified dimensions when adjusting. 5 Adjust PAL S.title Used for manual adjustment of the PAL S.title screen. Select this mode for S.title screen color matching and distortion adjustment. Use the specified dimensions when adjusting.

6 PAL to NTSC (Wide) PAL Wide/4:3 screen data is calculated, converted to NTSC Wide/4:3 approximate

data and saved. To assure accurate adjustments, select the manual mode explained below and check, then apply color matching and distortion adjustments.

7 PAL to NTSC (All) Data for all PAL screens is converted to approximate data for the NTSC screens and

saved. To assure accurate adjustments, select the manual mode explained below and check, then apply color matching and distortion adjustments. 8 Adjust NTSC Wide Used for manual adjustment of the NTSC Wide/4:3 screen. Select this mode for Wide/4:3 screen color matching and distortion adjustment. Use the specified dimensions when adjusting.

9 NTSC Wide to others Approximate supplementary data for the other NTSC screens is automatically saved

based on the NTSC Wide/4:3 screen data. First, the NTSC Wide/4:3 screen data are converted to Super Live and the values are saved. Next, the data are converted to Cinema and the values are saved. Finally, the data are converted to Subtitle and the values are saved, and then the operation ends. Manually check the other screen modes as described below and make corrections if distortion, etc., is present. Please be aware that all NTSC screens are re-adjusted when this menu is selected and executed. 1-3. Adjusting Screen 1) Adjusting menu

– 26 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS ItemNO Description 10 Adjust NTSC S.Live Used for manual adjustment of the NTSC Super Live screen. Select this mode for Super Live screen color matching and distortion adjustment. Use the specified dimensions when adjusting. 11 Adjust NTSC Cinema Used for manual adjustment of the NTSC Cinema screen. Select this mode for Cinema screen color matching and distortion adjustment. Use the specified dimensions when adjusting. 12 Adjust NTSC S.title Used for manual adjustment of the NTSC Subtitle screen. Select this mode for Subtitle screen color matching and distortion adjustment. Use the specified dimensions when adjusting. 3) Adjustment Sequence When the initial screen opens, X = 1, Y = 1, C = R and S = [Select Menu] are displayed as the defaults. The cursor can now be moved up, down, left and right using the (2), (8), (4) and (6) keys of the remote control. Select the desired adjustment and press the (5) key; the cursor will light steady and the screen display will be cleared. Again press the (2), (8), (4) and (6) keys of the remote control to adjust the shape of the screen. When adjustment has been completed, press the (+) key to return to the Adjustment Menu. When all of the screen adjustments have been completed, turn off the main power supply of the set to reset the menu. 2) Adjustment Screen X : 1 Y : 1 C : R S : 08Displayed when the cursor blinks and cleared when the cursor lights steady. X Cursor horizontal position display Y Cursor vertical position display C Cursor color select display S Menu select display Displayed when the cursor blinks and cleared when the cursor lights steady. Displays the current screen mode. Wide

– 27 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS 2. Case Study In many cases, color matching problems can be solved by returning the HIT and WID data for main deflection to the initial adjustment values. Convergence cannot be re-adjusted in the following cases. 2-1 When the CRT has been replaced Main deflection re-adjustment and color matching are necessary when the CRT has been replaced. Use the following procedure. 1. Replace the blue and red CRTs. 2. Perform the blue and red yoke horizontal adjustments in relation to the green CRT. Press the yokes and speed modulation coils + alignments onto the CRTs and fasten after making sure that there are no gaps. 3. Adjust the blue and red alignments (refer to the detailed alignment adjustment item). 4. Use centering magnets to center the blue and red CRTs in relation to the green CRT. 5. Adjust the main deflection HIT and WID data, using the most accurate location in relation to the green as data. 6. Use convergence to match the colors for each screen. Green will not work at this time. 7. When the convergence adjustments have been completed for all screens, then replace the green CRT. Repeat the procedures in steps 2 - 5 for the green CRT but this time use convergence to match the colors using red and blue as reference. 2-2 When replacing the convergence unit Generally, all of the screens must be re-adjusted when the convergence unit is replaced, but the process can be greatly shortened by using the following method. 1. Replace the memory (Q711, Q712, Q713) of the new unit with the memory (Q711, Q712, Q713) of the defective unit. This makes it possible to quickly reproduce the previous screen status when installed in the set. 2. Install the new unit with the old memory in the set and turn on the power. The entire screen will move linearly in either the vertical or horizontal direction. 3. Use centering magnets to re-adjust the green, red and blue centers. 4. There is possibility of color mismatching or differences in screen size when the various screens are checked. In such case, adjust the main deflection and apply a slight amount of convergence color matching. 2-3 When none of the above cases apply (rare case) An unexpected situation or major operational error, etc., could be considered but it is recommended that all screens be matched starting from the beginning. If the initial positions of the centering magnets are unknown, disconnect the connectors for the convergence sub-yoke outputs one at a time, adjust the CRT centering and then start the following adjustments. 1. Make sure that there is plenty of room for the static cross convergence to be moved left, right, up and down. If sufficient space is not available, move to an appropriate location and then re-adjust the centering. 2. Enter the convergence adjustment mode and call out the menu. (Leave the PAL signal connected.) 3. Select 1. Adjust PAL Wide and adjust the PAL mode Wide/4:3 screen manually in accordance with the dimension diagram. 4. When the Wide/4:3 screen adjustment has been completed, return to the Main Menu and select 2. PAL Wide to others. The screen will change automatically and the Wide, Cinema and Subtitle screens will be created automatically. 5. Next, select 3. Adjust PAL S.Live and mainly adjust in the horizontal direction in accordance with the dimension diagram. 6. Next, select 4. Adjust PAL Cinema and fine adjust to remove any Cinema screen distortion. 7. Next, select 5. Adjust PAL Subtitle and fine adjust to remove any Subtitle screen distortion. 8. Next, select 7. PAL to NTSC (ALL), then calculate and copy the data for all PAL screens in the NTSC mode. At this time, the calculations and screen shape changes will be performed automatically and the NTSC screen data corresponding to the PAL screens will be transferred. Subtitle, check the respective NTSC screen modes and, if necessary, adjust for any distortion. All of the screens can be adjusted with the above process but make every effort not to change the factory data unless absolutely necessary. Try not to change the convergence data any more than necessary.

– 28 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS

3 Screen adjustment dimensions

3-1 WIDE/4:3 (PAL mode) 3-2 Super Wide (PAL mode) 441 220.5 73.5 367.5 441 220.5 73.5 367.5 235 207.5 124.5 41.5 41.5 235 207.5 124.5 441 220.5 73.5 367.5 441 220.5 73.5 367.5 249.0 220.0 130.5 49.5 249.0 221.0 136.5 (screen center) (pattern center) Caution: Do not perform the VLIN adjustment.

– 29 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS 3-3 Cinema (PAL mode) Note: The cursor will move outside the screen limits in the Cinema mode; therefore, be careful to consider the position of the cursor displayed on the screen when making adjustments. 441 220.5 73.5 367.5 441 220.5 73.5 367.5 262.5 227.5 157.5 52.5 52.5 262.5 227.5 157.5 3-4 Subtitle (PAL mode) Note: The cursor will move outside the screen limits in the Subtitle mode; therefore, be careful to consider the position of the cursor displayed on the screen when making adjustments. Note: Please be aware that the Subtitle screen convergence pattern center is located at the center of the screen but the image center is located approximately 13mm above that. 441 220.5 73.5 367.5 441 220.5 73.5 367.5 272 240 240 272 144 144 Screen limit changed

– 30 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS 3-5 WIDE/4:3 (NTSC mode) 441 220.5 73.5 367.5 441 220.5 73.5 367.5 231 198 231 198 441 220.5 73.5 367.5 441 220.5 73.5 367.5 213 249 105 249 216 112 Caution: Do not perform the VLIN adjustment. 3-6 Super Live (NTSC mode) (screen center) (pattern center)

– 31 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS 3-7 Cinema (NTSC mode) Note: The cursor will move outside the screen limits in the Cinema mode; therefore, be careful to consider the position of the cursor displayed on the screen when making adjustments. Note: Please be aware that the Cinema screen convergence pattern center is located at the center of the screen but the image center is located approximately 13mm above that. 441 220.5 73.5 367.5 441 220.5 73.5 367.5 266 228 114 266 114 228 3-8 Subtitle (NTSC mode) Note: The cursor will move outside the screen limits in the Subtitle mode; therefore, be careful to consider the position of the cursor displayed on the screen when making adjustments. Note: Please be aware that the Subtitle screen convergence pattern center is located at the center of the screen but the image center is located approximately 32mm above that. 441 220.5 73.5 367.5 441 220.5 73.5 367.5 287 246 123 287 246 123

– 32 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS SCREEN AND MIRROR ALIGNMENTS CAUTION : Do not hold the optical system parts (lens and mirror) with bare hand to avoid finger-prints on the surface of those parts. HOW TO CLEAN LENS AND MIRROR 1. Be sure to remove sand dust with an air brush, etc. 2. When it is stained slightly, breathe upon it and wipe away with the specified cleaning cloth. For other stains than the above, wipe the stains away with the specified cloth into which a cleaning liquid has been soaked. by Edmund Scientific Co.), etc. HOW TO CLEAN SCREEN When cleaning the screen, use a soft cloth so as not to dam- age the screen. 1. Wipe the stain away with a diluted neutral detergent soaked cloth. 2. Wipe the detergent away with a water soaked cloth. 3. Wipe the screen with a dry cloth to remove moisture on the screen. Note : Absolutely do not use alcohol, benzine, thinner, etc. for cleaning in order not to wipe away the black print on the surface. ASSEMBLING AND MOUNTING OF FRONT SCREEN CLEANING OF LENS AND MIRROR * Please refer to MECHANICAL DISASSEMBL Y page.38.

– 33 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS CIRCUIT CHECKS HIGH VOLTAGE CHECK CAUTION: There is no HIGH VOLTAGE ADJUSTMENT on this chassis. Checking should be done following the steps below. 1. Connect an accurate high voltage meter to the anode of the picture tube. 2. Turn on the receiver. Set the BRIGHTNESS and CONTRAST to minimum (zero beam current). 3. High voltage must be measured below (B) kV. Refer to table-1 for high voltage (B). (See SETTING & ADJUSTING DA TA on page 34) 4. Vary the BRIGHTNESS to both extremes to be sure the high voltage does not exceed the limit under any conditions. CAUTION: When the following parts fail, check the High Voltage after replacing. ANODE VOLTAGE MEASURING METHOD CAUTION: Take extra precaution when measuring this high voltage. High voltages are also present in surrounding circuit boards (CRT DRIVE assembly, DEFLECTION assembly, and POWER SUPPL Y assembly). 1. Disconnect the FBT anode cable as outlined below. Measure high voltage at the point where the cable enters the FBT. 2. Holding the rubber cover firmly, turn it counterclockwise and check that the lock has been disengaged. (See Fig. b on page 8.) 3. Determine the extent of the rubber cover before disconnecting the cable. 4. Pull straight up the anode cable to disconnect. 5. When reconnecting the cable, proceed in the reverse order. After reconnecting, tug on the cable to check that it is secure. Location No. Name Name T461 D489 Q480 Q483 R435 R489 R490 R450 C440 C443 C444 Flyback Trans. Zener Diode Transistor IC Resistor Resistor Resistor VR Capacitor Capacitor Capacitor TFB3078BD MTZJ3.6B 2SC2023 TA7508P(J) 33k ohm, ±5% 3.3k ohm, ±5% 3.3k ohm, ±5% 1k ohm 1000pF , ±3% 6800pF , ±3% 5100pF , ±3%

– 34 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS SETTING & ADJUSTING DATA 40" HIGH VOLTAGE AT ZERO BEAM: (A) 31.9 kV MAX HIGH VOLTAGE: (B) 32.5 kV AV VOLTAGE (C) 230 V CHAPTER 2 SPECIFIC INFORMATIONS SAFETY INSTRUCTIONS Table-1 SERVICE MODE ADJUSTING ITEMS AND DATAS IN THE SERVICE MODE: Table-2 RCUT GCUT BCUT RDRV BDRV CNTX BRTC COLC TNTC COLP COLS SCNT BELL SRY SBY R CUTOFF (B/W) G CUTOFF (B/W) B CUTOFF (B/W) R DRIVE B DRIVE SUB CONTRAST MAX SUB BRIGHT CEN SUB COLOR CEN NTSC SUB TINT CEN SUB COLOR CEN PAL SUB COLOR CEN SECAM SUB CONTRAST SECAM BELL FILTER SECAM R-Y SECAM B-Y Item Adjustment Reference data 40H 40H 40H 40H 40H 7FH 80H FDH 45H 50H 38H 07H 80H 08H 08H Item Adjustment Reference data HPOS VPOS HIT GMPS VLIN VSC VPS VCP WID PARA CNR TRAP HCP VFC 50Hz H-POSITION V-POSITION HEIGHT V-POSITION (RASTER) V-LINEARITY V-S CORRECTION V-SHIFT V-COMPENSATION PICTURE WIDTH E-W PARABOLA E-W CORNER TRAPEZIUM H-COMPENSATION V-F CORRECTION 0CH 01H 26H 00H 15H 26H 12H 05H 1EH 02H 10H 40H 04H 0FH DESIGN MODE ADJUSTING ITEMS AND DATAS IN THE DESIGN MODE: RCUT OPT1 OPT0 OSD RCUT Table-3 OPTION 1 OPTION 0 4CH 80H 4CH 4CH 80H 81H Item Name of adjustment Preset Data 40PW03G 40PW03B Remarks

– 35 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS LOCATION OF CONTROLS Front Back WOOFER SWITCH WOOFER OUT VIDEO-1 (21PINS FULL) VIDEO-2 (21PINS S-VIDEO/AV) AERIAL TERMINAL AUDIO OUT (FIXED) VIDEO-3 (S-VIDEO/AUDIO) VIDEO-3 (21PINS S-VIDEO/AUDIO) HEAD PHONE (VIDEO-3) S-VIDEO TERMINAL VIDEO-3 MENU VOLUME DOWN VOLUME UP POSITION DOWN MAIN SWITCH POWER (RED) ON TIMER (GREEN) BILINGUAL (ORANGE) STEREO (GREEN) EXIT POSITION UP

– 36 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS CH F f v ? ^ yX SIZE V TEXT CALL MENU EXIT REC VTR/DVD ENTER SELECT -/-- Çi 2 3 4 5 6 7 8 9 0 a P Remote Controller F Keypad Number Buttons Teletext SIZE Menu Control Buttons MENU Buttons Video Recoder Buttons to operate your Toshiba Video Recorder 1 or 2 Digit Channel Selection Power ON/ OFF CALL Teletext

• Programme Position up/down VIDEO (+F) Picture Controls Menu Control Buttons ENTER EXIT
• Stereo/Bilingual
• Sound Mute Volume

– 37 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS CIRCUIT BLOCK DIAGRAM MICRO COMPUTER MEMORY QA01 Q801 I2CBUS QA02 QV01 AV SW R,G,B TEXT QZ01 Q501 R G B QQ01 QQ02 Q601 CRT.R CRT.G CRT.B MAIN/CENTER Q901 Q911 Q921 Q301 Q404 Q751,Q752 QW51,QW52 DIGITAL COM. MAIN AUDIO OUT VIDEO OUT VIDEO OUT VIDEO OUT SVM.OUT V.OUT H.OUT CONVER OUT DIGITAL CONVER DPC.OUT PROTECTOR : I2C BLOCK SW.REG. E/W CORRECTION SECAM 1H DELAY COLOR/VIDEO/DEF T862 Z801

21 PIN

(FULL) (S+AV) (S+AV) S VIDEO FRONT S+AV AUDIO FIX OUT Y/V L,R OSD QR01 QF01 R,G,B V L,R L,R QR01 RGB, SW L,R V V Y TIF H001 MA H002

– 38 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS MECHANICAL DISASSEMBLY K502

16 SCREWS

10 SCREWS

8 SCREWS

A213 (A214) (A223) A102 A103 K101 K102 K103

6 SCREWS

– 39 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS WARNING : BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION PRECAUTION”, “SAFETY PRECAUTION” AND “PRODUCT SAFETY NOTICE” ON PAGE 3 OF THIS MANUAL. CAUTION : The international hazard symbols “” in the schematic diagram and the parts list designate com- ponents which have special characteristics important for safety and should be replaced only with types identical to those in the original circuit or specified in the parts list. The mounting position of replacements is to be identical with originals. Before replacing any of these components, read carefully the PRODUCT SAFETY NOTICE . Do not degrade the safety of the receiver through improper servicing. NOTICE:

• The part number must be used when ordering parts, in order to assist in processing, be sure to include the Model number and Description.
• The PC board assembly with * mark is no longer available after the end of the production. ABBREVIATIONS: OMF : Oxide Metal Film VR : Variable Resistor FR : Fusible Resistor (All CD and PF capacitors are ±5%, 50V and all resistors, ±5%, 1/6W unless otherwise noted.) CHASSIS AND CABINET REPLACEMENT PARTS LIST Models : 40PW03G, 40PW03B Location No. Part No. Description Location No. Part No. Description CAPACITORSCAPACITORSCAPACITORSCAPACITORSCAPACITORS C101 24793220 EL, 22?F, ±20%, 10V C102 24762221 EL, 220?F, ±20%, 10V C105 24212102 CD, 1000pF, ±10% C106 24797100 EL, 10?F, ±20%, 50V C115 24232103 CD, 0.01?F, +80%, -20% C116 24762221 EL, 220?F, ±20%, 10V C150 24763102 EL, 1000?F, ±20%, 16V C183 24766479 EL, 4.7?F, ±20%, 50V C194 24232103 CD, 0.01?F, +80%, -20% C201 24538104 PF, 0.1?F C202 24814103 Chip, 0.01?F, +80%, -20% C203 24538104 PF, 0.1?F C204 24669010 EL, 1?F, ±20%, 50V C205 24669229 EL, 2.2?F, ±20%, 50V C206 24206220 EL, 22?F, ±20%, 50V C212 24794100 EL, 10?F, ±20%, 16V C214 24591334 PF, 0.33?F C219 24781100 Chip, 10pF, ±0.5pF%, SL C220 24781100 Chip, 10pF, ±0.5pF%, SL C221 24781100 Chip, 10pF, ±0.5pF%, SL C228 24814103 Chip, 0.01?F, +80%, -20% C229 24669010 EL, 1?F, ±20%, 50V C230 24763221 EL, 220?F, ±20%, 16V C231 24814103 Chip, 0.01?F, +80%, -20% C232 24669010 EL, 1?F, ±20%, 50V C260 24085967 EL, 47?F, ±20%, 16V, Non-Polar C261 24669101 EL, 100?F, ±20%, 50V C262 24814103 Chip, 0.01?F, +80%, -20% C264 24781150 Chip, 15pF, SL C273 24206229 EL, 2.2?F, ±20%, 50V C281 24763101 EL, 100?F, ±20%, 16V C282 24232103 CD, 0.01?F, +80%, -20% C283 24794100 EL, 10?F, ±20%, 16V C284 24794100 EL, 10?F, ±20%, 16V C295 24232103 CD, 0.01?F, +80%, -20% C303 24214471 CD, 470pF, ±10%, 500V C305 24617912 EL, 2.2?F, ±10%, 50V C306 24617858 EL, 3300?F, ±20%, 35V C307 24082270 PF, 0.033?F, 100V C308 24669221 EL, 220?F, ±20%, 50V C309 24212101 CD, 100pF, ±10% C310 24669222 EL, 2200?F, ±20%, 50V C311 24214561 CD, 560pF, ±10%, 500V C313 24082057 PF, 0.22?F, 100V C314 24591103 PF, 0.01?F C315 24797229 EL, 2.2?F, ±20%, 50V C316 24232103 CD, 0.01?F, +80%, -20% C318 24666222 EL, 2200?F, ±20%, 16V C319 24591102 PF, 1000pF C320 24669101 EL, 100?F, ±20%, 50V C321 24591183 PF, 0.018?F C322 24617915 EL, 1?F, ±10%, 50V C323 24567474 PF, 0.47?F C324 24567684 PF, 0.68?F C330 24591104 PF, 0.1?F C331 24669229 EL, 2.2?F, ±20%, 50V C344 24591103 PF, 0.01?F C351 24667222 EL, 2200?F, ±20%, 25V C355 24669010 EL, 1?F, ±20%, 50V C357 24669100 EL, 10?F, ±20%, 50V C360 24667100 EL, 10?F, ±20%, 25V C361 24669100 EL, 10?F, ±20%, 50V C362 24591104 PF, 0.1?F C363 24085942 EL, 10?F, ±20%, 16V, Non-Polar C364 24666100 EL, 10?F, ±20%, 16V C370 24669101 EL, 100?F, ±20%, 50V C371 24669100 EL, 10?F, ±20%, 50V C372 24591104 PF, 0.1?F C388 24591334 PF, 0.33?F C403 24591223 PF, 0.022?F C403 24828124 PF, 0.12?F, 200V C404 24797229 EL, 2.2?F, ±20%, 50V C413 24214821 CD, 820pF, ±10%, 500V C415 24815392 Chip, 3900pF, ±10% C416 24678100 EL, 10?F, ±20%, 200V C417 24214391 CD, 390pF, ±10%, 500V C418 24095883 PF, 0.015?F, ±3%, 630V C419 24095803 PF, 0.062?F, 400V C420 24666101 EL, 100?F, ±20%, 16V

– 40 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description C423 24095779 PF, 0.062?F, 400V C430 24814103 Chip, 0.01?F, +80%, -20% C431 24763102 EL, 1000?F, ±20%, 16V C440 24082326 PF, 1300pF, ±3%, 1500V C443 24082348 PF, 6800pF, ±3%, 1500V C444 24082287 PF, 5100pF, ±3%, 1800V C445 24828473 PF, 0.047?F, 200V C446 24679330 EL, 33?F, ±20%, 250V C447 24667102 EL, 1000?F, ±20%, 25V C448 24640908 EL, 33?F, ±20%, 160V C460 24669331 EL, 330?F, ±20%, 50V C463 24212152 CD, 1500pF, ±10% C464 24640872 EL, 10?F, ±20%, 100V C465 24591332 PF, 3300pF C466 24567394 PF, 0.39?F C467 24820153 PF, 0.015?F, 630V C468 24567474 PF, 0.47?F C471 24206479 EL, 4.7?F, ±20%, 50V C475 24820103 PF, 0.01?F, 630V C477 24092347 CD, 1500pF, ±10%, 2kV C481 24567104 PF, 0.1?F C482 24591152 PF, 1500pF C483 24567224 PF, 0.22?F C484 24567104 PF, 0.1?F C485 24669101 EL, 100?F, ±20%, 50V C493 24591124 PF, 0.12?F C501 24781101 Chip, 100pF, SL C502 24814103 Chip, 0.01?F, +80%, -20% C503 24763221 EL, 220?F, ±20%, 16V C504 24591222 PF, 2200pF C505 24774120 Chip, 12pF, CH C507 24774120 Chip, 12pF, CH C508 24669010 EL, 1?F, ±20%, 50V C509 24763101 EL, 100?F, ±20%, 16V C510 24763101 EL, 100?F, ±20%, 16V C511 24814103 Chip, 0.01?F, +80%, -20% C512 24206228 EL, 0.22?F, ±20%, 50V C513 24814103 Chip, 0.01?F, +80%, -20% C514 24538104 PF, 0.1?F C515 24538104 PF, 0.1?F C516 24781102 Chip, 1000pF, SL C517 24774010 Chip, 1pF, ±0.25pF, CH C519 24774010 Chip, 1pF, ±0.25pF, CH C520 24781102 Chip, 1000pF, SL C521 24781102 Chip, 1000pF, SL C524 24781122 Chip, 1200pF, SL C525 24774181 Chip, 180pF, CH C554 24814103 Chip, 0.01?F, +80%, -20% C555 24669010 EL, 1?F, ±20%, 50V C556 24669010 EL, 1?F, ±20%, 50V C601 24590102 PF, 1000pF C602 24590102 PF, 1000pF C603 24669100 EL, 10?F, ±20%, 50V C604 24669100 EL, 10?F, ±20%, 50V C605 24667101 EL, 100?F, ±20%, 25V C606 24667101 EL, 100?F, ±20%, 25V C607 24538104 PF, 0.1?F(40PW03G) C607 24567104 PF, 0.1?F(40PW03B) C608 24538104 PF, 0.1?F(40PW03G) C608 24567104 PF, 0.1?F(40PW03B) C609 24669102 EL, 1000?F, ±20%, 50V C610 24669102 EL, 1000?F, ±20%, 50V C611 24667221 EL, 220?F, ±20%, 25V C613 24666471 EL, 470?F, ±20%, 16V C636 24666100 EL, 10?F, ±20%, 16V C661 24436101 CD, 100pF C665 24669229 EL, 2.2?F, ±20%, 50V C666 24669229 EL, 2.2?F, ±20%, 50V C671 24669100 EL, 10?F, ±20%, 50V C672 24232103 CD, 0.01?F, +80%, -20% C673 24781102 Chip, 1000pF, SL C674 24669100 EL, 10?F, ±20%, 50V C674 24781102 Chip, 1000pF, SL C675 24669100 EL, 10?F, ±20%, 50V C675 24781102 Chip, 1000pF, SL C676 24669100 EL, 10?F, ±20%, 50V C676 24781102 Chip, 1000pF, SL C677 24668221 EL, 220?F, ±20%, 35V C678 24781102 Chip, 1000pF, SL C679 24781102 Chip, 1000pF, SL C680 24669222 EL, 2200?F, ±20%, 50V C681 24781102 Chip, 1000pF, SL C682 24669010 EL, 1?F, ±20%, 50V C682 24781102 Chip, 1000pF, SL C696 24762102 EL, 1000?F, ±20%, 10V C701 24781330 Chip, 33pF, SL C702 24781330 Chip, 33pF, SL C711 24206100 EL, 10?F, ±20%, 50V C714 24092293 Chip, 0.1?F, +80%, -20%, 25V C715 24092441 Chip, 1?F, +80%, -20%, 16V C716 24815822 Chip, 0.0082?F, ±10% C717 24774470 Chip, 47pF, CH C718 24774470 Chip, 47pF, CH C719 24794101 EL, 100?F, ±20%, 16V C720 24092293 Chip, 0.1?F, +80%, -20%, 25V C721 24567104 PF, 0.1?F C722 24092293 Chip, 0.1?F, +80%, -20%, 25V C724 24092293 Chip, 0.1?F, +80%, -20%, 25V C725 24092293 Chip, 0.1?F, +80%, -20%, 25V C726 24092293 Chip, 0.1?F, +80%, -20%, 25V C727 24092293 Chip, 0.1?F, +80%, -20%, 25V C728 24763221 EL, 220?F, ±20%, 16V C729 24092293 Chip, 0.1?F, +80%, -20%, 25V C730 24567104 PF, 0.1?F C731 24766010 EL, 1?F, ±20%, 50V C732 24590822 PF, 0.0082?F C735 24092293 Chip, 0.1?F, +80%, -20%, 25V C736 24794470 EL, 47?F, ±20%, 16V C739 24092293 Chip, 0.1?F, +80%, -20%, 25V C740 24092293 Chip, 0.1?F, +80%, -20%, 25V C741 24794470 EL, 47?F, ±20%, 16V C742 24794470 EL, 47?F, ±20%, 16V C743 24092293 Chip, 0.1?F, +80%, -20%, 25V C744 24092293 Chip, 0.1?F, +80%, -20%, 25V C745 24794470 EL, 47?F, ±20%, 16V C746 24794470 EL, 47?F, ±20%, 16V C747 24092293 Chip, 0.1?F, +80%, -20%, 25V C748 24092293 Chip, 0.1?F, +80%, -20%, 25V C749 24794470 EL, 47?F, ±20%, 16V C750 24794470 EL, 47?F, ±20%, 16V C756 24781391 Chip, 390pF, SL C761 24590182 PF, 1800pF C762 24590562 PF, 5600pF C763 24774391 Chip, 390pF, CH C765 24590182 PF, 1800pF C766 24590562 PF, 5600pF C767 24774391 Chip, 390pF, CH C769 24590182 PF, 1800pF

– 41 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description C770 24590562 PF, 5600pF C771 24774391 Chip, 390pF, CH C773 24590182 PF, 1800pF C774 24590562 PF, 5600pF C775 24774391 Chip, 390pF, CH C777 24590182 PF, 1800pF C778 24590562 PF, 5600pF C779 24774391 Chip, 390pF, CH C781 24590182 PF, 1800pF C782 24590562 PF, 5600pF C783 24774391 Chip, 390pF, CH C795 24761221 EL, 220?F, ±20%, 6.3V C798 24763101 EL, 100?F, ±20%, 16V C799 24763101 EL, 100?F, ±20%, 16V *C801 24082374 PF, 0.22?F, ±20%, AC250V *C802 24092557 CD, 220pF, ±20%, AC250V *C803 24092557 CD, 220pF, ±20%, AC250V *C804 24092570 CD, 3300pF, ±20%, AC250V *C805 24082374 PF, 0.22?F, ±20%, AC250V C807 24073058 EL, 2200?F, ±20%, 25V C808 24617787 EL, 470?F, ±20%, 16V C809 24567105 PF, 1?F C810 24086935 EL, 560?F, ±20%, 400V C811 24676478 EL, 0.47?F, ±20%, 100V C812 24092281 CD, 4700pF, ±20%, AC250V C813 24092281 CD, 4700pF, ±20%, AC250V C814 24678229 EL, 2.2?F, ±20%, 200V C815 24567474 PF, 0.47?F C816 24617817 EL, 22?F, ±20%, 50V C817 24567224 PF, 0.22?F C819 24214102 CD, 1000pF, ±10%, 500V C820 24567224 PF, 0.22?F C821 24092480 CD, 680pF, ±10%, 2kV C822 24092481 CD, 820pF, ±10%, 2kV C823 24092478 CD, 470pF, ±10%, 2kV C824 24214103 CD, 0.01?F, ±10%, 500V C825 24591472 PF, 4700pF C826 24092474 CD, 220pF, ±10%, 2kV C828 24820683 PF, 0.068?F, 630V C829 24617820 EL, 100?F, ±20%, 50V C830 24567105 PF, 1?F C831 24669220 EL, 22?F, ±20%, 50V C853 24668102 EL, 1000?F, ±20%, 35V C855 24214471 CD, 470pF, ±10%, 500V C856 24214471 CD, 470pF, ±10%, 500V C857 24214471 CD, 470pF, ±10%, 500V C858 24214471 CD, 470pF, ±10%, 500V C859 24214471 CD, 470pF, ±10%, 500V C860 24669471 EL, 470?F, ±20%, 50V C861 24668332 EL, 3300?F, ±20%, 35V C862 24668471 EL, 470?F, ±20%, 35V C863 24668332 EL, 3300?F, ±20%, 35V C864 24668471 EL, 470?F, ±20%, 35V C865 24214471 CD, 470pF, ±10%, 500V C866 24214471 CD, 470pF, ±10%, 500V C867 24214471 CD, 470pF, ±10%, 500V C868 24214471 CD, 470pF, ±10%, 500V C869 24669222 EL, 2200?F, ±20%, 50V C870 24214471 CD, 470pF, ±10%, 500V C871 24214471 CD, 470pF, ±10%, 500V C872 24214471 CD, 470pF, ±10%, 500V C873 24214471 CD, 470pF, ±10%, 500V C874 24212102 CD, 1000pF, ±10% C875 24667472 EL, 4700?F, ±20%, 25V C876 24086916 EL, 330?F, ±20%, 160V C877 24092475 CD, 220pF, ±10%, 2kV C878 24092475 CD, 220pF, ±10%, 2kV C879 24092475 CD, 220pF, ±10%, 2kV C880 24092475 CD, 220pF, ±10%, 2kV C881 24567474 PF, 0.47?F C882 24617817 EL, 22?F, ±20%, 50V C883 24082229 PF, 0.1?F, ±10%, 250V C884 24617816 EL, 10?F, ±20%, 50V C885 24617813 EL, 2.2?F, ±20%, 50V C886 24677470 EL, 47?F, ±20%, 160V C889 24669010 EL, 1?F, ±20%, 50V C891 24669010 EL, 1?F, ±20%, 50V C901 24211102 CD, 1000pF, ±10%, 2kV C902 24794100 EL, 10?F, ±20%, 16V C903 24232103 CD, 0.01?F, +80%, -20% C904 24436391 CD, 390pF C905 24214102 CD, 1000pF, ±10%, 500V C911 24211102 CD, 1000pF, ±10%, 2kV C912 24794100 EL, 10?F, ±20%, 16V C913 24232103 CD, 0.01?F, +80%, -20% C914 24436561 CD, 560pF C915 24679330 EL, 33?F, ±20%, 250V C915A 23960136 Adhesive, TSE3843-W C916 24794101 EL, 100?F, ±20%, 16V C921 24211102 CD, 1000pF, ±10%, 2kV C922 24794100 EL, 10?F, ±20%, 16V C924 24232103 CD, 0.01?F, +80%, -20% C926 24436471 CD, 470pF C941 24797478 EL, 0.47?F, ±20%, 50V C943 24667102 EL, 1000?F, ±20%, 25V C944 24206100 EL, 10?F, ±20%, 50V C961 24666101 EL, 100?F, ±20%, 16V C962 24203100 EL, 10?F, ±20%, 16V C963 24232103 CD, 0.01?F, +80%, -20% C964 24591104 PF, 0.1?F C6101 24232103 CD, 0.01?F, +80%, -20% C6102 24232103 CD, 0.01?F, +80%, -20% C7701 24761221 EL, 220?F, ±20%, 6.3V C7703 24232103 CD, 0.01?F, +80%, -20% C7721 24212102 CD, 1000pF, ±10% C7722 24436101 CD, 100pF C7724 24667101 EL, 100?F, ±20%, 25V C7725 24667101 EL, 100?F, ±20%, 25V C7726 24212102 CD, 1000pF, ±10% C7727 24436101 CD, 100pF C7729 24212102 CD, 1000pF, ±10% C7730 24436101 CD, 100pF C7732 24212102 CD, 1000pF, ±10% C7733 24436101 CD, 100pF C7735 24667101 EL, 100?F, ±20%, 25V C7736 24669101 EL, 100?F, ±20%, 50V C7737 24212102 CD, 1000pF, ±10% C7738 24436101 CD, 100pF C7740 24212102 CD, 1000pF, ±10% C7741 24436101 CD, 100pF C7742 24436330 CD, 33pF C7743 24436330 CD, 33pF C7747 24667101 EL, 100?F, ±20%, 25V C7748 24567104 PF, 0.1?F C7749 24567104 PF, 0.1?F C7750 24667101 EL, 100?F, ±20%, 25V C7751 24667101 EL, 100?F, ±20%, 25V C7752 24567104 PF, 0.1?F

– 42 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description C7753 24567104 PF, 0.1?F C7754 24667101 EL, 100?F, ±20%, 25V C7755 24667101 EL, 100?F, ±20%, 25V C7756 24567104 PF, 0.1?F C7757 24567104 PF, 0.1?F C7758 24667101 EL, 100?F, ±20%, 25V C7760 24667470 EL, 47?F, ±20%, 25V C7761 24667470 EL, 47?F, ±20%, 25V C7762 24669100 EL, 10?F, ±20%, 50V C7763 24667470 EL, 47?F, ±20%, 25V C7764 24598331 PF, 330pF C7767 24667470 EL, 47?F, ±20%, 25V C7768 24567104 PF, 0.1?F C7769 24232103 CD, 0.01?F, +80%, -20% C7770 24669470 EL, 47?F, ±20%, 50V C7771 24567103 PF, 0.01?F C7772 24667101 EL, 100?F, ±20%, 25V C7773 24669101 EL, 100?F, ±20%, 50V C7774 24436331 CD, 330pF C7775 24667101 EL, 100?F, ±20%, 25V C7776 24667470 EL, 47?F, ±20%, 25V C7777 24669470 EL, 47?F, ±20%, 50V C7778 24567104 PF, 0.1?F C7779 24669479 EL, 4.7?F, ±20%, 50V C7780 24591102 PF, 1000pF C8301 24666101 EL, 100?F, ±20%, 16V C8303 24669100 EL, 10?F, ±20%, 50V C8304 24666101 EL, 100?F, ±20%, 16V C8306 24666470 EL, 47?F, ±20%, 16V C8307 24591334 PF, 0.33?F C9602 24794100 EL, 10?F, ±20%, 16V CA14 24232103 CD, 0.01?F, +80%, -20% CA15 24232103 CD, 0.01?F, +80%, -20% CA19 24436101 CD, 100pF CA24 24436101 CD, 100pF CA41 24436101 CD, 100pF CA42 24436101 CD, 100pF CA43 24436101 CD, 100pF CA68 24794100 EL, 10?F, ±20%, 16V CA69 24232103 CD, 0.01?F, +80%, -20% CA106 24436101 CD, 100pF CA107 24538104 PF, 0.1?F(40PW03G) CA107 24567104 PF, 0.1?F(40PW03B) CA108 24538103 PF, 0.01?F(40PW03G) CA108 24590103 PF, 0.01?F(40PW03B) CA109 24538103 PF, 0.01?F(40PW03G) CA109 24590103 PF, 0.01?F(40PW03B) CA420 24794100 EL, 10?F, ±20%, 16V CA430 24232103 CD, 0.01?F, +80%, -20% CA440 24232103 CD, 0.01?F, +80%, -20% CB01 24794470 EL, 47?F, ±20%, 16V CB90 24232103 CD, 0.01?F, +80%, -20% CC08 24815102 Chip, 0.001?F, ±10% CC10 24781820 Chip, 82pF, SL CC15 24212102 CD, 1000pF, ±10% CC23 24814103 Chip, 0.01?F, +80%, -20% CC28 24232103 CD, 0.01?F, +80%, -20% CC29 24232103 CD, 0.01?F, +80%, -20% CC30 24567474 PF, 0.47?F CC39 24232103 CD, 0.01?F, +80%, -20% CC40 24781470 Chip, 47pF, SL CC41 24781470 Chip, 47pF, SL CC42 24781470 Chip, 47pF, SL CC45 24774050 CD, 5pF, ±0.25pF, CH CC46 24774050 CD, 5pF, ±0.25pF, CH CC47 24232103 CD, 0.01?F, +80%, -20% CC48 24232103 CD, 0.01?F, +80%, -20% CF03 24567104 PF, 0.1?F CF04 24766101 EL, 100?F, ±20%, 50V CF05 24766101 EL, 100?F, ±20%, 50V CF06 24774220 Chip, 22pF, CH CF07 24774220 Chip, 22pF, CH CF08 24567104 PF, 0.1?F CF09 24567104 PF, 0.1?F CF10 24206100 EL, 10?F, ±20%, 50V CF11 24567104 PF, 0.1?F CF12 24814103 Chip, 0.01?F, +80%, -20% CF14 24814103 Chip, 0.01?F, +80%, -20% CF16 24567224 PF, 0.22?F CF18 24794101 EL, 100?F, ±20%, 16V CF19 24814103 Chip, 0.01?F, +80%, -20% CF20 24766010 EL, 1?F, ±20%, 50V CQ01 24781102 Chip, 1000pF, SL CQ02 24781820 Chip, 82pF, SL CQ03 24781102 Chip, 1000pF, SL CQ04 24203100 EL, 10?F, ±20%, 16V CQ05 24591563 PF, 0.056?F CQ07 24591203 PF, 0.02?F CQ08 24567683 PF, 0.068?F CQ09 24206229 EL, 2.2?F, ±20%, 50V CQ10 24591223 PF, 0.022?F CQ11 24206229 EL, 2.2?F, ±20%, 50V CQ12 24781820 Chip, 82pF, SL CQ13 24669010 EL, 1?F, ±20%, 50V CQ14 24669010 EL, 1?F, ±20%, 50V CQ15 24763101 EL, 100?F, ±20%, 16V CQ16 24814103 Chip, 0.01?F, +80%, -20% CQ17 24774150 Chip, 15pF, CH CQ18 24781820 Chip, 82pF, SL CQ19 24590103 PF, 0.01?F CQ20 24567104 PF, 0.1?F CQ21 24794470 EL, 47?F, ±20%, 16V CQ22 24814103 Chip, 0.01?F, +80%, -20% CQ23 24567104 PF, 0.1?F CQ24 24567104 PF, 0.1?F CQ25 24797100 EL, 10?F, ±20%, 50V CQ26 24567104 PF, 0.1?F CQ27 24567104 PF, 0.1?F CQ28 24797478 EL, 0.47?F, ±20%, 50V CQ29 24794101 EL, 100?F, ±20%, 16V CQ30 24814103 Chip, 0.01?F, +80%, -20% CQ31 24797478 EL, 0.47?F, ±20%, 50V CQ32 24590103 PF, 0.01?F CQ33 24567104 PF, 0.1?F CQ34 24567104 PF, 0.1?F CQ35 24206478 EL, 0.47?F, ±20%, 50V CQ36 24206478 EL, 0.47?F, ±20%, 50V CQ37 24669010 EL, 1?F, ±20%, 50V CQ38 24669010 EL, 1?F, ±20%, 50V CQ39 24669010 EL, 1?F, ±20%, 50V CQ40 24781820 Chip, 82pF, SL CQ41 24781090 Chip, 9pF, ±0.5pF, SL CQ42 24781090 Chip, 9pF, ±0.5pF, SL CQ43 24781090 Chip, 9pF, ±0.5pF, SL CQ45 24781102 Chip, 1000pF, SL CQ46 24781102 Chip, 1000pF, SL CQ61 24781102 Chip, 1000pF, SL CQ62 24781470 Chip, 47pF, SL

– 43 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description CQ63 24781470 Chip, 47pF, SL CR01 24206010 EL, 1?F, ±20%, 50V CR01 24567104 PF, 0.1?F CR02 24232103 CD, 0.01?F, +80%, -20% CR02 24567104 PF, 0.1?F CR03 24436101 CD, 100pF CR03 24567104 PF, 0.1?F CR04 24567104 PF, 0.1?F CR05 24567104 PF, 0.1?F CR06 24567104 PF, 0.1?F CR07 24814103 Chip, 0.01?F, +80%, -20% CR08 24794100 EL, 10?F, ±20%, 16V CR09 24538104 PF, 0.1?F(40PW03G) CR09 24567104 PF, 0.1?F CR09 24814103 Chip, 0.01?F, +80%, -20% CR10 24794470 EL, 47?F, ±20%, 16V CR11 24538104 PF, 0.1?F(40PW03G) CR11 24567104 PF, 0.1?F(40PW03B) CR12 24567104 PF, 0.1?F CR13 24567104 PF, 0.1?F CR14 24567104 PF, 0.1?F CR18 24538104 PF, 0.1?F(40PW03G) CR18 24567104 PF, 0.1?F(40PW03B) CR19 24538104 PF, 0.1?F(40PW03G) CR19 24567104 PF, 0.1?F(40PW03B) CR20 24538104 PF, 0.1?F(40PW03G) CR20 24567104 PF, 0.1?F(40PW03B) CS01 24085944 EL, 2.2?F, ±20%, 50V, Non-Polar CS02 24085944 EL, 2.2?F, ±20%, 50V, Non-Polar CS03 24206229 EL, 2.2?F, ±20%, 50V CS04 24206229 EL, 2.2?F, ±20%, 50V CS05 24206229 EL, 2.2?F, ±20%, 50V CS06 24206229 EL, 2.2?F, ±20%, 50V CS07 24206229 EL, 2.2?F, ±20%, 50V CS08 24206229 EL, 2.2?F, ±20%, 50V CS12 24781102 Chip, 1000pF, SL CS13 24781102 Chip, 1000pF, SL CS14 24206100 EL, 10?F, ±20%, 50V CS15 24206100 EL, 10?F, ±20%, 50V CS17 24203100 EL, 10?F, ±20%, 16V CS18 24203100 EL, 10?F, ±20%, 16V CS19 24206478 EL, 0.47?F, ±20%, 50V CS22 24203100 EL, 10?F, ±20%, 16V CS23 24203100 EL, 10?F, ±20%, 16V CS53 24781102 Chip, 1000pF, SL CV01 24567103 PF, 0.01?F CV02 24085970 EL, 10?F, ±20%, 16V, Non-Polar CV03 24203100 EL, 10?F, ±20%, 16V CV04 24203100 EL, 10?F, ±20%, 16V CV05 24814103 Chip, 0.01?F, +80%, -20% CV06 24203100 EL, 10?F, ±20%, 16V CV08 24763102 EL, 1000?F, ±20%, 16V CV10 24085970 EL, 10?F, ±20%, 16V, Non-Polar CV11 24781331 Chip, 330pF, SL CV12 24092178 Chip, 0.1?F, ±10%, 25V CV13 24814103 Chip, 0.01?F, +80%, -20% CV14 24781102 Chip, 1000pF, SL CV15 24781102 Chip, 1000pF, SL CV16 24781102 Chip, 1000pF, SL CV17 24781102 Chip, 1000pF, SL CV18 24781102 Chip, 1000pF, SL CV19 24781102 Chip, 1000pF, SL CV20 24781430 Chip, 43pF, SL CV23 24203101 EL, 100?F, ±20%, 16V CV24 24814103 Chip, 0.01?F, +80%, -20% CV25 24763471 EL, 470?F, ±20%, 16V CV31 24781102 Chip, 1000pF, SL CV34 24781102 Chip, 1000pF, SL CV35 24814103 Chip, 0.01?F, +80%, -20% CV37 24781102 Chip, 1000pF, SL CV39 24203101 EL, 100?F, ±20%, 16V CV40 24814103 Chip, 0.01?F, +80%, -20% CV46 24212332 CD, 3300pF, ±10% CV47 24212332 CD, 3300pF, ±10% CV48 24212102 CD, 1000pF, ±10% CV65 24203101 EL, 100?F, ±20%, 16V CV66 24203101 EL, 100?F, ±20%, 16V CV67 24763471 EL, 470?F, ±20%, 16V CV68 24763471 EL, 470?F, ±20%, 16V CV78 24781330 Chip, 33pF, SL CW01 24781121 Chip, 120pF, SL CW02 24781121 Chip, 120pF, SL CW03 24781470 Chip, 47pF, SL CW04 24085945 EL, 2.2?F, ±20%, 50V, Non-Polar CW04 24591822 PF, 8200pF CW05 24212103 CD, 0.01?F, ±10% CW05 24781121 Chip, 120pF, SL CW06 24781121 Chip, 120pF, SL CW07 24206229 EL, 2.2?F, ±20%, 50V CW07 24666470 EL, 47?F, ±20%, 16V CW08 24781121 Chip, 120pF, SL CW09 24781121 Chip, 120pF, SL CW10 24206229 EL, 2.2?F, ±20%, 50V CW11 24781330 Chip, 33pF, SL CW12 24666470 EL, 47?F, ±20%, 16V CW12 24781820 Chip, 82pF, SL CW13 24781330 Chip, 33pF, SL CW13 24790100 EL, 10?F, ±20%, 160V CW14 24436101 CD, 100pF CW14 24781820 Chip, 82pF, SL CW15 24214472 CD, 4700pF, ±10%, 500V CW15 24781330 Chip, 33pF, SL CW16 24436101 CD, 100pF CW16 24781820 Chip, 82pF, SL CW17 24214472 CD, 4700pF, ±10%, 500V CW18 24666470 EL, 47?F, ±20%, 16V CW19 24435560 CD, 56pF, 500V CW20 24790100 EL, 10?F, ±20%, 160V CW21 24794470 EL, 47?F, ±20%, 16V CW22 24212561 CD, 560pF, ±10% CW26 24212102 CD, 1000pF, ±10% CW27 24085986 EL, 10?F, ±20%, 10V, Non-Polar CW28 24085986 EL, 10?F, ±20%, 10V, Non-Polar CW29 24085986 EL, 10?F, ±20%, 10V, Non-Polar CW30 24202221 EL, 220?F, ±20%, 10V 16V CW32 24781331 Chip, 330pF, SL 16V

– 44 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description CW34 24814103 Chip, 0.01?F, +80%, -20% CW35 24092293 Chip, 0.1?F, +80%, -20%, 25V CW36 24814103 Chip, 0.01?F, +80%, -20% CW37 24814103 Chip, 0.01?F, +80%, -20% CW38 24202101 EL, 100?F, ±20%, 10V CW39 24092293 Chip, 0.1?F, +80%, -20%, 25V CW40 24203101 EL, 100?F, ±20%, 16V CW41 24092293 Chip, 0.1?F, +80%, -20%, 25V CW42 24201101 EL, 100?F, 6.3V CW43 24092293 Chip, 0.1?F, +80%, -20%, 25V CW44 24201101 EL, 100?F, 6.3V CW45 24092293 Chip, 0.1?F, +80%, -20%, 25V CW46 24206010 EL, 1?F, ±20%, 50V CW47 24092293 Chip, 0.1?F, +80%, -20%, 25V CW48 24092293 Chip, 0.1?F, +80%, -20%, 25V CW49 24092293 Chip, 0.1?F, +80%, -20%, 25V CW50 24202221 EL, 220?F, ±20%, 10V CW51 24092293 Chip, 0.1?F, +80%, -20%, 25V CW52 24092293 Chip, 0.1?F, +80%, -20%, 25V CW53 24092293 Chip, 0.1?F, +80%, -20%, 25V CW54 24092293 Chip, 0.1?F, +80%, -20%, 25V CW55 24815472 Chip, 0.0047?F, ±10% CW56 24781221 Chip, 220pF, SL CW60 24092441 Chip, 1?F, +80%, -20%, 16V CW61 24781182 Chip, 1800pF, SL CW62 24781182 Chip, 1800pF, SL CW68 24092293 Chip, 0.1?F, +80%, -20%, 25V CW70 24814103 Chip, 0.01?F, +80%, -20% CW72 24567103 PF, 0.01?F CW73 24774471 Chip, 470pF, CH CW74 24814103 Chip, 0.01?F, +80%, -20% CW75 24092293 Chip, 0.1?F, +80%, -20%, 25V CW80 24092441 Chip, 1?F, +80%, -20%, 16V CW81 24092441 Chip, 1?F, +80%, -20%, 16V CW82 24781330 Chip, 33pF, SL CW83 24781330 Chip, 33pF, SL CW85 24781330 Chip, 33pF, SL CW86 24781330 Chip, 33pF, SL CW87 24781330 Chip, 33pF, SL CW88 24781330 Chip, 33pF, SL CW89 24781330 Chip, 33pF, SL CW90 24781330 Chip, 33pF, SL CW91 24781330 Chip, 33pF, SL CW92 24781330 Chip, 33pF, SL CW93 24781330 Chip, 33pF, SL CW94 24781101 Chip, 100pF, SL CW95 24781101 Chip, 100pF, SL CW97 24781101 Chip, 100pF, SL 16V CZ05 24814103 Chip, 0.01?F, +80%, -20% CZ07 24092178 Chip, 0.1?F, ±10%, 25V CZ09 24781220 Chip, 22pF, SL CZ10 24781100 Chip, 10pF, ±0.5pF%, SL CZ11 24781220 Chip, 22pF, SL CZ12 24814103 Chip, 0.01?F, +80%, -20% CZ13 24814103 Chip, 0.01?F, +80%, -20% CZ14 24203100 EL, 10?F, ±20%, 16V CZ17 24814103 Chip, 0.01?F, +80%, -20% CZ19 24781181 Chip, 180pF, SL CZ20 24815103 Chip, 0.01?F, ±10% CZ21 24781122 Chip, 1200pF, SL CZ22 24203100 EL, 10?F, ±20%, 16V CZ23 24814103 Chip, 0.01?F, +80%, -20% CZ24 24814103 Chip, 0.01?F, +80%, -20% CZ25 24203100 EL, 10?F, ±20%, 16V CZ26 24814103 Chip, 0.01?F, +80%, -20% CZ28 24814103 Chip, 0.01?F, +80%, -20% CZ29 24814103 Chip, 0.01?F, +80%, -20% CZ30 24203100 EL, 10?F, ±20%, 16V CZ31 24092178 Chip, 0.1?F, ±10%, 25V CZ32 24781470 Chip, 47pF, SL CZ33 24781470 Chip, 47pF, SL CZ34 24781470 Chip, 47pF, SL CZ35 24781470 Chip, 47pF, SL CZ45 24781100 Chip, 10pF, ±0.5pF%, SL RESISTORSRESISTORSRESISTORSRESISTORSRESISTORS R101 24382223 OMF, 22k ohm, 1W R201 24872101 Chip, 100 ohm, 1/16W R204 24872104 Chip, 100k ohm, 1/16W R205 24872101 Chip, 100 ohm, 1/16W R206 24872471 Chip, 470 ohm, 1/16W R207 24872103 Chip, 10k ohm, 1/16W R208 24872103 Chip, 10k ohm, 1/16W R209 24872103 Chip, 10k ohm, 1/16W R210 24872101 Chip, 100 ohm, 1/16W R211 24872101 Chip, 100 ohm, 1/16W R212 24872101 Chip, 100 ohm, 1/16W R213 24872681 Chip, 680 ohm, 1/16W R214 24872681 Chip, 680 ohm, 1/16W R215 24872681 Chip, 680 ohm, 1/16W R216 24872103 Chip, 10k ohm, 1/16W R218 24872101 Chip, 100 ohm, 1/16W R219 24872101 Chip, 100 ohm, 1/16W R220 24872101 Chip, 100 ohm, 1/16W R222 24872333 Chip, 33k ohm, 1/16W R223 24872332 Chip, 3300 ohm, 1/16W R229 24872272 Chip, 2700 ohm, 1/16W R231 24000824 Chip, Jumper, 2125 type R239 24000824 Chip, Jumper, 2125 type R260 24872153 Chip, 15k ohm, 1/16W R261 24872682 Chip, 6800 ohm, 1/16W R266 24872102 Chip, 1k ohm, 1/16W R267 24872182 Chip, 1800 ohm, 1/16W R268 24872101 Chip, 100 ohm, 1/16W R269 24872821 Chip, 820 ohm, 1/16W R273 24872473 Chip, 47k ohm, 1/16W R274 24872102 Chip, 1k ohm, 1/16W R275 24872101 Chip, 100 ohm, 1/16W R276 24872683 Chip, 68k ohm, 1/16W R277 24872103 Chip, 10k ohm, 1/16W R281 24366821 CF, 820 ohm R282 24366102 CF, 1k ohm R283 24366472 CF, 4700 ohm R291 24366123 CF, 12k ohm R292 24366103 CF, 10k ohm R293 24366333 CF, 33k ohm R295 24366102 CF, 1k ohm R296 24366101 CF, 100 ohm R297 24366102 CF, 1k ohm R298 24366113 CF, 11k ohm R299 24366153 CF, 15k ohm R301 24366102 CF, 1k ohm R302 24366101 CF, 100 ohm R303 24321129 MF, 1.2 ohm, 1/2W R304 24366223 CF, 22k ohm R305 24322828 MF, 0.82 ohm, 1W

– 45 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description R306 24366333 CF, 33k ohm R307 24366224 CF, 220k ohm R308 24382391 OMF, 390 ohm, 1W R312 24366103 CF, 10k ohm R313 24366153 CF, 15k ohm R315 24366102 CF, 1k ohm R316 24366105 CF, 1M ohm R317 24366104 CF, 100k ohm R318 24366101 CF, 100 ohm R319 24366101 CF, 100 ohm R321 24872682 Chip, 6800 ohm, 1/16W R327 24000187 FR, 3.3 ohm, 1W R329 24366103 CF, 10k ohm R330 24366102 CF, 1k ohm R331 24366152 CF, 1500 ohm R332 24366222 CF, 2200 ohm R333 24366823 CF, 82k ohm R334 24366823 CF, 82k ohm R335 24366104 CF, 100k ohm R336 24383221 OMF, 220 ohm, 2W R341 24366622 CF, 6200 ohm R343 24366153 CF, 15k ohm R346 24366102 CF, 1k ohm R351 24552101 OMF, 100 ohm, 1/2W R352 24366222 CF, 2200 ohm R353 24366682 CF, 6800 ohm R354 24366222 CF, 2200 ohm R356 24366562 CF, 5600 ohm R357 24382114 OMF, 110k ohm, 1W R358 24366682 CF, 6800 ohm R359 24366103 CF, 10k ohm R360 24366102 CF, 1k ohm R361 24366113 CF, 11k ohm R362 24366754 CF, 750k ohm R363 24366103 CF, 10k ohm R364 24366103 CF, 10k ohm R365 24366103 CF, 10k ohm R366 24366103 CF, 10k ohm R367 24366473 CF, 47k ohm R368 24366473 CF, 47k ohm R369 24366102 CF, 1k ohm R370 24321159 MF, 1.5 ohm, 1/2W R371 24366682 CF, 6800 ohm R372 24366472 CF, 4700 ohm R373 24366152 CF, 1500 ohm R374 24366473 CF, 47k ohm R375 24366102 CF, 1k ohm R376 24384221 OMF, 220 ohm, 3W R377 24384221 OMF, 220 ohm, 3W R378 24366102 CF, 1k ohm R379 24366562 CF, 5600 ohm R386 24366472 CF, 4700 ohm R388 24366392 CF, 3900 ohm R390 24382561 OMF, 560 ohm, 1W R391 24382561 OMF, 560 ohm, 1W R392 24382561 OMF, 560 ohm, 1W R393 24366184 CF, 180k ohm R394 24366153 CF, 15k ohm R400 24942102 CC, 1k ohm, 1/2W R401 24366103 CF, 10k ohm R401 24872391 Chip, 390 ohm, 1/16W R402 24366333 CF, 33k ohm R402 24872103 Chip, 10k ohm, 1/16W R403 24366332 CF, 3300 ohm R403 24872302 Chip, 3k ohm, 1/16W R404 24383270 OMF, 27 ohm, 2W R405 24382332 OMF, 3300 ohm, 1W R407 24872103 Chip, 10k ohm, 1/16W R408 24321209 MF, 2 ohm, 1/2W R409 24381103 OMF, 10k ohm, 1/2W R410 24366331 CF, 330 ohm R411 24366471 CF, 470 ohm R415 24553272 OMF, 2700 ohm, 1W R416 24510562 Cement, 5600 ohm, 5W R421 24872334 Chip, 330k ohm, 1/16W R422 24872152 Chip, 1500 ohm, 1/16W R423 24872152 Chip, 1500 ohm, 1/16W R424 24546338 FR, 0.33 ohm, 1/2W R425 24552331 OMF, 330 ohm, 1/2W R425 24872153 Chip, 15k ohm, 1/16W R426 24366821 CF, 820 ohm R427 24366432 CF, 4300 ohm R428 24366561 CF, 560 ohm R429 24552330 OMF, 33 ohm, 1/2W R431 24382100 OMF, 10 ohm, 1W R432 24532560 FR, 56 ohm, 1W R434 24366102 CF, 1k ohm R435 24366333 CF, 33k ohm R436 24327224 MF, 220k ohm, ±1%, 1/4W R439 24366472 CF, 4700 ohm R441 24383102 OMF, 1k ohm, 2W R443 24310109 MF, 1.0 ohm, 1/2W R444 24338398 MF, 0.39 ohm, 1W R445 24382332 OMF, 3300 ohm, 1W R446 24382332 OMF, 3300 ohm, 1W R447 24382473 OMF, 47k ohm, 1W R448 24338828 MF, 0.82 ohm, 1W R450 24066879 VR, 1k ohm, 0.3W R451 24376223 CF, 22k ohm, 1/2W R452 24376223 CF, 22k ohm, 1/2W R453 24376223 CF, 22k ohm, 1/2W R454 24366223 CF, 22k ohm R455 24366333 CF, 33k ohm R460 24552332 OMF, 3300 ohm, 1/2W R461 24366332 CF, 3300 ohm R462 24366102 CF, 1k ohm R462 24366912 CF, 9100 ohm R463 24339109 MF, 1 ohm, 2W R464 24366273 CF, 27k ohm R465 24366114 CF, 110k ohm R466 24366152 CF, 1500 ohm R469 24000465 FR, 9.1 ohm, 1W R472 24552270 OMF, 27 ohm, 1/2W R476 24366821 CF, 820 ohm R477 24383121 OMF, 120 ohm, 2W R478 24376333 CF, 33k ohm, 1/2W R479 24366101 CF, 100 ohm R480 24553332 OMF, 3300 ohm, 1W R481 24366473 CF, 47k ohm R482 24366103 CF, 10k ohm R483 24366154 CF, 150k ohm R484 24366473 CF, 47k ohm R485 24552271 OMF, 270 ohm, 1/2W R487 24366472 CF, 4700 ohm R488 24366474 CF, 470k ohm R489 24366332 CF, 3300 ohm R490 24366332 CF, 3300 ohm R492 24366102 CF, 1k ohm

– 46 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description R493 24552392 OMF, 3900 ohm, 1/2W R494 24366183 CF, 18k ohm R495 24366682 CF, 6800 ohm R496 24382114 OMF, 110k ohm, 1W R498 24366153 CF, 15k ohm R499 24366824 CF, 820k ohm R501 24872223 Chip, 22k ohm, 1/16W R502 24872101 Chip, 100 ohm, 1/16W R503 24872101 Chip, 100 ohm, 1/16W R505 24872102 Chip, 1k ohm, 1/16W R506 24872103 Chip, 10k ohm, 1/16W R508 24872102 Chip, 1k ohm, 1/16W R509 24872102 Chip, 1k ohm, 1/16W R510 24872472 Chip, 4700 ohm, 1/16W R511 24872101 Chip, 100 ohm, 1/16W R515 24366102 CF, 1k ohm R516 24366101 CF, 100 ohm R516 24872101 Chip, 100 ohm, 1/16W R517 24872101 Chip, 100 ohm, 1/16W R518 24872472 Chip, 4700 ohm, 1/16W R519 24872101 Chip, 100 ohm, 1/16W R520 24872103 Chip, 10k ohm, 1/16W R521 24872223 Chip, 22k ohm, 1/16W R522 24872473 Chip, 47k ohm, 1/16W R532 24000824 Chip, Jumper, 2125 type R533 24000824 Chip, Jumper, 2125 type R534 24000824 Chip, Jumper, 2125 type R601 24366332 CF, 3300 ohm R602 24366332 CF, 3300 ohm R603 24366222 CF, 2200 ohm R604 24366222 CF, 2200 ohm R605 24366229 CF, 2.2 ohm R606 24366229 CF, 2.2 ohm R607 24366682 CF, 6800 ohm R608 24366682 CF, 6800 ohm R610 24366104 CF, 100k ohm R611 24366103 CF, 10k ohm R612 24366103 CF, 10k ohm R613 24366224 CF, 220k ohm R614 24366103 CF, 10k ohm R635 24366224 CF, 220k ohm R636 24366104 CF, 100k ohm R661 24366103 CF, 10k ohm R670 24552182 OMF, 1800 ohm, 1/2W R671 24366153 CF, 15k ohm R672 24366153 CF, 15k ohm R673 24366563 CF, 56k ohm R674 24366563 CF, 56k ohm R675 24366103 CF, 10k ohm R676 24872223 Chip, 22k ohm, 1/16W R677 24366104 CF, 100k ohm R677 24872223 Chip, 22k ohm, 1/16W R678 24366103 CF, 10k ohm R678 24872223 Chip, 22k ohm, 1/16W R679 24366103 CF, 10k ohm R679 24872223 Chip, 22k ohm, 1/16W R680 24872223 Chip, 22k ohm, 1/16W R681 24872223 Chip, 22k ohm, 1/16W R682 24366473 CF, 47k ohm R683 24366223 CF, 22k ohm R684 24366223 CF, 22k ohm R688 24366222 CF, 2200 ohm R688 24552391 OMF, 390 ohm, 1/2W R690 24552391 OMF, 390 ohm, 1/2W R690 24872681 Chip, 680 ohm, 1/16W R691 24872681 Chip, 680 ohm, 1/16W R692 24872681 Chip, 680 ohm, 1/16W R693 24872681 Chip, 680 ohm, 1/16W R701 24872221 Chip, 220 ohm, 1/16W R702 24872221 Chip, 220 ohm, 1/16W R703 24872472 Chip, 4700 ohm, 1/16W R704 24872472 Chip, 4700 ohm, 1/16W R705 24872472 Chip, 4700 ohm, 1/16W R706 24872472 Chip, 4700 ohm, 1/16W R707 24872100 Chip, 10 ohm, 1/16W R708 24872100 Chip, 10 ohm, 1/16W R709 24872100 Chip, 10 ohm, 1/16W R710 24872100 Chip, 10 ohm, 1/16W R711 24872100 Chip, 10 ohm, 1/16W R712 24872100 Chip, 10 ohm, 1/16W R713 24872100 Chip, 10 ohm, 1/16W R714 24872100 Chip, 10 ohm, 1/16W R715 24872153 Chip, 15k ohm, 1/16W R716 24872103 Chip, 10k ohm, 1/16W R717 24872622 Chip, 6200 ohm, 1/16W R718 24872152 Chip, 1500 ohm, 1/16W R720 24872103 Chip, 10k ohm, 1/16W R721 24872223 Chip, 22k ohm, 1/16W R722 24872222 Chip, 2200 ohm, 1/16W R725 24872754 Chip, 750k ohm, 1/16W R726 24872331 Chip, 330 ohm, 1/16W R727 24871221 Chip, 220 ohm, 1/8W R728 24872393 Chip, 39k ohm, 1/16W R729 24872153 Chip, 15k ohm, 1/16W R735 24872911 Chip, 910 ohm, 1/16W R736 24872911 Chip, 910 ohm, 1/16W R737 24872152 Chip, 1500 ohm, 1/16W R738 24872332 Chip, 3300 ohm, 1/16W R739 24872362 Chip, 3600 ohm, 1/16W R740 24872911 Chip, 910 ohm, 1/16W R741 24872911 Chip, 910 ohm, 1/16W R742 24872152 Chip, 1500 ohm, 1/16W R743 24872332 Chip, 3300 ohm, 1/16W R744 24872362 Chip, 3600 ohm, 1/16W R745 24872911 Chip, 910 ohm, 1/16W R746 24872911 Chip, 910 ohm, 1/16W R747 24872152 Chip, 1500 ohm, 1/16W R748 24872332 Chip, 3300 ohm, 1/16W R749 24872362 Chip, 3600 ohm, 1/16W R750 24872911 Chip, 910 ohm, 1/16W R751 24872911 Chip, 910 ohm, 1/16W R752 24872152 Chip, 1500 ohm, 1/16W R753 24872332 Chip, 3300 ohm, 1/16W R754 24872362 Chip, 3600 ohm, 1/16W R755 24872911 Chip, 910 ohm, 1/16W R756 24872911 Chip, 910 ohm, 1/16W R757 24872152 Chip, 1500 ohm, 1/16W R758 24872332 Chip, 3300 ohm, 1/16W R759 24872362 Chip, 3600 ohm, 1/16W R760 24872911 Chip, 910 ohm, 1/16W R761 24872911 Chip, 910 ohm, 1/16W R762 24872152 Chip, 1500 ohm, 1/16W R763 24872332 Chip, 3300 ohm, 1/16W R764 24872362 Chip, 3600 ohm, 1/16W R778 24872101 Chip, 100 ohm, 1/16W R779 24872101 Chip, 100 ohm, 1/16W R780 24872101 Chip, 100 ohm, 1/16W R781 24872101 Chip, 100 ohm, 1/16W

– 47 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description R782 24872101 Chip, 100 ohm, 1/16W R783 24872101 Chip, 100 ohm, 1/16W R786 24872472 Chip, 4700 ohm, 1/16W R787 24872472 Chip, 4700 ohm, 1/16W R801 24366473 CF, 47k ohm R802 24366102 CF, 1k ohm R803 24366683 CF, 68k ohm R805 24366101 CF, 100 ohm R806 24366101 CF, 100 ohm R807 24367273 CF, 27k ohm, ±2% R808 24552470 OMF, 47 ohm, 1/2W R809 24321689 OMF, 6.8 ohm, 1/2W R810 24383680 OMF, 68 ohm, 2W R811 24552121 OMF, 120 ohm, 1/2W R812 24552390 OMF, 39 ohm, 1/2W R814 24552821 OMF, 820 ohm, 1/2W R816 24384223 OMF, 22k ohm, 3W *R819 24009954 Metal-Glazed Resistor, 2.2M ohm, 1/2W R820 24007061 Cement, 1.8 ohm, ±10%, 2W R821 24510479 Cement, 4.7 ohm, 5W R822 24366102 CF, 1k ohm R823 24554470 OMF, 47 ohm, 2W R851 24545109 FR, 1 ohm, 1/4W R852 24366272 CF, 2700 ohm R853 24338568 MF, 0.56 ohm, 1W R854 24553121 OMF, 120 ohm, 1W R855 24553271 OMF, 270 ohm, 1W R856 24366152 CF, 1500 ohm R857 24381682 OMF, 6800 ohm, 1/2W R858 24366102 CF, 1k ohm R859 24382333 OMF, 33k ohm, 1W R860 24366102 CF, 1k ohm *R861 24005015 Metal-Glazed Resistor, 8.2M ohm, 1W R862 24366223 CF, 22k ohm R863 24366101 CF, 100 ohm R870 24552100 OMF, 10 ohm, 1/2W R901 24366101 CF, 100 ohm R903 24942102 CC, 1k ohm, 1/2W R905 24366390 CF, 39 ohm R906 24366621 CF, 620 ohm R908 24366680 CF, 68 ohm R909 24366151 CF, 150 ohm R911 24366101 CF, 100 ohm R913 24942102 CC, 1k ohm, 1/2W R915 24366390 CF, 39 ohm R916 24366621 CF, 620 ohm R918 24366680 CF, 68 ohm R921 24366101 CF, 100 ohm R923 24942102 CC, 1k ohm, 1/2W R925 24366151 CF, 150 ohm R926 24366621 CF, 620 ohm R928 24366101 CF, 100 ohm R931 24555153 OMF, 15k ohm, 3W R932 24555153 OMF, 15k ohm, 3W R933 24000929 FR, 1.5 ohm, 1W R935 24366150 CF, 15 ohm R936 24366330 CF, 33 ohm R941 24555153 OMF, 15k ohm, 3W R942 24555153 OMF, 15k ohm, 3W R943 24366103 CF, 10k ohm R944 24366150 CF, 15 ohm R945 24366680 CF, 68 ohm R946 24366330 CF, 33 ohm R949 24366121 CF, 120 ohm R951 24555153 OMF, 15k ohm, 3W R952 24555153 OMF, 15k ohm, 3W R953 24366390 CF, 39 ohm R956 24366102 CF, 1k ohm R957 24366330 CF, 33 ohm R961 24366102 CF, 1k ohm R962 24366361 CF, 360 ohm R964 24366332 CF, 3300 ohm R965 24366471 CF, 470 ohm R966 24366821 CF, 820 ohm R967 24366102 CF, 1k ohm R968 24366680 CF, 68 ohm R969 24366103 CF, 10k ohm R970 24366222 CF, 2200 ohm R971 24367152 CF, 1500 ohm, ±2% R972 24367471 CF, 470 ohm, ±2% R973 24367681 CF, 680 ohm, ±2% R974 24367681 CF, 680 ohm, ±2% R975 24366242 CF, 2400 ohm R976 24367562 CF, 5600 ohm, ±2% R977 24367472 CF, 4700 ohm, ±2% R978 24367681 CF, 680 ohm, ±2% R6101 24366473 CF, 47k ohm R6102 24366103 CF, 10k ohm R6103 24366331 CF, 330 ohm R7703 24366473 CF, 47k ohm R7704 24366103 CF, 10k ohm R7705 24366472 CF, 4700 ohm R7706 24366222 CF, 2200 ohm R7707 24366472 CF, 4700 ohm R7708 24366472 CF, 4700 ohm R7710 24384680 OMF, 68 ohm, 3W R7711 24323229 MF, 2.2 ohm, 2W R7712 24366472 CF, 4700 ohm R7713 24366472 CF, 4700 ohm R7715 24384680 OMF, 68 ohm, 3W R7716 24323229 MF, 2.2 ohm, 2W R7717 24366472 CF, 4700 ohm R7718 24366472 CF, 4700 ohm R7720 24384680 OMF, 68 ohm, 3W R7721 24323229 MF, 2.2 ohm, 2W R7722 24366472 CF, 4700 ohm R7723 24366472 CF, 4700 ohm R7725 24384680 OMF, 68 ohm, 3W R7726 24323229 MF, 2.2 ohm, 2W R7727 24366472 CF, 4700 ohm R7728 24366472 CF, 4700 ohm R7730 24384680 OMF, 68 ohm, 3W R7731 24323229 MF, 2.2 ohm, 2W R7732 24366472 CF, 4700 ohm R7733 24366472 CF, 4700 ohm R7735 24384680 OMF, 68 ohm, 3W R7736 24323229 MF, 2.2 ohm, 2W R7738 24383101 OMF, 100 ohm, 2W R7741 24366471 CF, 470 ohm R7742 24366472 CF, 4700 ohm R7743 24366223 CF, 22k ohm R7744 24366102 CF, 1k ohm R7745 24366222 CF, 2200 ohm R7746 24366223 CF, 22k ohm R7747 24366222 CF, 2200 ohm R7749 24366331 CF, 330 ohm

– 48 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description R7750 24323278 MF, 0.27 ohm, 2W R7751 24366471 CF, 470 ohm R7752 24366101 CF, 100 ohm R7753 24366101 CF, 100 ohm R7754 24366101 CF, 100 ohm R7755 24366102 CF, 1k ohm R7757 24366223 CF, 22k ohm R7758 24366222 CF, 2200 ohm R7763 24366471 CF, 470 ohm R7764 24366331 CF, 330 ohm R7765 24339398 MF, 0.39 ohm, 2W R7766 24366223 CF, 22k ohm R7767 24366223 CF, 22k ohm R7768 24366102 CF, 1k ohm R7770 24366153 CF, 15k ohm R7771 24366102 CF, 1k ohm R7772 24366102 CF, 1k ohm R7775 24366273 CF, 27k ohm R7776 24366472 CF, 4700 ohm R7777 24366273 CF, 27k ohm R7778 24366472 CF, 4700 ohm R7779 24366102 CF, 1k ohm R7780 24366102 CF, 1k ohm R7781 24366333 CF, 33k ohm R7782 24339828 MF, 0.82 ohm, 2W R7783 24366331 CF, 330 ohm R7784 24366471 CF, 470 ohm R7785 24366222 CF, 2200 ohm R7786 24366103 CF, 10k ohm R7787 24366104 CF, 100k ohm R7788 24366103 CF, 10k ohm R7789 24366471 CF, 470 ohm R7790 24552182 OMF, 1800 ohm, 1/2W R7791 24552681 OMF, 680 ohm, 1/2W R7792 24366471 CF, 470 ohm R7793 24552182 OMF, 1800 ohm, 1/2W R7794 24366223 CF, 22k ohm R8301 24366473 CF, 47k ohm R8302 24366273 CF, 27k ohm R9601 24366101 CF, 100 ohm R9602 24366362 CF, 3600 ohm R9603 24366392 CF, 3900 ohm R9604 24366272 CF, 2700 ohm R9605 24366682 CF, 6800 ohm R9606 24366362 CF, 3600 ohm R9613 24366560 CF, 56 ohm R9614 24366560 CF, 56 ohm R9615 24366101 CF, 100 ohm R9616 24366102 CF, 1k ohm RA01 24366102 CF, 1k ohm RA02 24366102 CF, 1k ohm RA03 24366102 CF, 1k ohm RA06 24366102 CF, 1k ohm RA07 24366102 CF, 1k ohm RA08 24366102 CF, 1k ohm RA09 24366102 CF, 1k ohm RA10 24366102 CF, 1k ohm RA11 24366102 CF, 1k ohm RA13 24366102 CF, 1k ohm RA14 24366102 CF, 1k ohm RA15 24366103 CF, 10k ohm RA19 24366331 CF, 330 ohm RA20 24366102 CF, 1k ohm RA21 24366102 CF, 1k ohm RA22 24366102 CF, 1k ohm RA24 24366153 CF, 15k ohm RA31 24366103 CF, 10k ohm RA32 24366103 CF, 10k ohm RA36 24366102 CF, 1k ohm RA37 24366102 CF, 1k ohm RA53 24366101 CF, 100 ohm RA55 24366101 CF, 100 ohm RA57 24366101 CF, 100 ohm RA59 24366102 CF, 1k ohm RA61 24366102 CF, 1k ohm RA62 24366102 CF, 1k ohm RA63 24366102 CF, 1k ohm RA70 24366333 CF, 33k ohm RA71 24366103 CF, 10k ohm RA71 24366683 CF, 68k ohm RA72 24366103 CF, 10k ohm RA72 24366223 CF, 22k ohm RA73 24366103 CF, 10k ohm RA75 24366333 CF, 33k ohm RA76 24366103 CF, 10k ohm RA77 24366223 CF, 22k ohm RA78 24366683 CF, 68k ohm RA91 24366103 CF, 10k ohm RA92 24366472 CF, 4700 ohm RA93 24366103 CF, 10k ohm RA96 24366103 CF, 10k ohm RA97 24366472 CF, 4700 ohm RA98 24366103 CF, 10k ohm RA99 24366562 CF, 5600 ohm RA104 24366682 CF, 6800 ohm RA105 24366103 CF, 10k ohm RA106 24366682 CF, 6800 ohm RA107 24366472 CF, 4700 ohm RA108 24366472 CF, 4700 ohm RA120 24366472 CF, 4700 ohm RA140 24366153 CF, 15k ohm RA150 24366103 CF, 10k ohm RA310 24366101 CF, 100 ohm RA410 24366273 CF, 27k ohm RB01 24366271 CF, 270 ohm RB02 24366471 CF, 470 ohm RB03 24366101 CF, 100 ohm RB04 24366223 CF, 22k ohm RB05 24366223 CF, 22k ohm RB07 24366271 CF, 270 ohm RB08 24366271 CF, 270 ohm RB09 24366470 CF, 47 ohm RB10 24366101 CF, 100 ohm RB11 24366103 CF, 10k ohm RB12 24366471 CF, 470 ohm RB40 24366103 CF, 10k ohm RB43 24366822 CF, 8200 ohm RB44 24366103 CF, 10k ohm RB45 24366101 CF, 100 ohm RB81 24366122 CF, 1200 ohm RB82 24366123 CF, 12k ohm RB83 24366123 CF, 12k ohm RB84 24366562 CF, 5600 ohm RB90 24366392 CF, 3900 ohm RB91 24366473 CF, 47k ohm RB92 24366271 CF, 270 ohm RB93 24366271 CF, 270 ohm RB94 24366222 CF, 2200 ohm

– 49 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description RB95 24366222 CF, 2200 ohm RB96 24366273 CF, 27k ohm RB97 24366273 CF, 27k ohm RB98 24366102 CF, 1k ohm RF01 24872332 Chip, 3300 ohm, 1/16W RF03 24872682 Chip, 6800 ohm, 1/16W RF04 24872223 Chip, 22k ohm, 1/16W RF06 24872102 Chip, 1k ohm, 1/16W RF08 23103832 Chip (Ferrite Bead), TEM2125M RF09 23103832 Chip (Ferrite Bead), TEM2125M RF10 23103832 Chip (Ferrite Bead), TEM2125M RF11 24872103 Chip, 10k ohm, 1/16W RF12 24872101 Chip, 100 ohm, 1/16W RF13 24872101 Chip, 100 ohm, 1/16W RF14 24872101 Chip, 100 ohm, 1/16W RF15 24872103 Chip, 10k ohm, 1/16W RF16 24872471 Chip, 470 ohm, 1/16W RF20 24872472 Chip, 4700 ohm, 1/16W RF21 24000824 Chip, Jumper, 2125 type RF22 24872102 Chip, 1k ohm, 1/16W RF24 24872102 Chip, 1k ohm, 1/16W RF26 24872102 Chip, 1k ohm, 1/16W RF27 24872103 Chip, 10k ohm, 1/16W RF28 24872102 Chip, 1k ohm, 1/16W RF29 24872103 Chip, 10k ohm, 1/16W RF30 24872103 Chip, 10k ohm, 1/16W RF38 24872153 Chip, 15k ohm, 1/16W RF39 24872472 Chip, 4700 ohm, 1/16W RJ02 24872101 Chip, 100 ohm, 1/16W RQ01 24872102 Chip, 1k ohm, 1/16W RQ03 24872102 Chip, 1k ohm, 1/16W RQ04 24872511 Chip, 510 ohm, 1/16W RQ05 24872471 Chip, 470 ohm, 1/16W RQ06 24872471 Chip, 470 ohm, 1/16W RQ07 24872103 Chip, 10k ohm, 1/16W RQ08 24872102 Chip, 1k ohm, 1/16W RQ09 24872102 Chip, 1k ohm, 1/16W RQ10 24872102 Chip, 1k ohm, 1/16W RQ11 24872561 Chip, 560 ohm, 1/16W RQ12 24872561 Chip, 560 ohm, 1/16W RQ13 24872203 Chip, 20k ohm, 1/16W RQ14 24872273 Chip, 27k ohm, 1/16W RQ20 24872563 Chip, 56k ohm, 1/16W RR01 24366102 CF, 1k ohm RR02 24366104 CF, 100k ohm RR03 24366222 CF, 2200 ohm RR04 24366101 CF, 100 ohm RR04 24872102 Chip, 1k ohm, 1/16W RR05 24366102 CF, 1k ohm RR05 24872102 Chip, 1k ohm, 1/16W RR06 24000824 Chip, Jumper, 2125 type RR06 24366223 CF, 22k ohm RR07 24000824 Chip, Jumper, 2125 type RR07 24366152 CF, 1500 ohm RR08 24366332 CF, 3300 ohm RR09 24000824 Chip, Jumper, 2125 type RR09 24366222 CF, 2200 ohm RR10 24366102 CF, 1k ohm RR10 24872103 Chip, 10k ohm, 1/16W RR11 24366152 CF, 1500 ohm RR11 24872473 Chip, 47k ohm, 1/16W RR12 24366152 CF, 1500 ohm RR12 24872102 Chip, 1k ohm, 1/16W RR13 24366152 CF, 1500 ohm RR13 24872622 Chip, 6200 ohm, 1/16W RR15 24366391 CF, 390 ohm RR16 24366391 CF, 390 ohm RR17 24366391 CF, 390 ohm RR20 24872103 Chip, 10k ohm, 1/16W RR22 24366103 CF, 10k ohm RR23 24366103 CF, 10k ohm RR24 24000824 Chip, Jumper, 2125 type RR25 24872102 Chip, 1k ohm, 1/16W RR28 24872473 Chip, 47k ohm, 1/16W RR29 24872473 Chip, 47k ohm, 1/16W RR31 24366331 CF, 330 ohm RR32 24366331 CF, 330 ohm RR32 24872331 Chip, 330 ohm, 1/16W RR33 24366331 CF, 330 ohm RR33 24872331 Chip, 330 ohm, 1/16W RR34 24366102 CF, 1k ohm RR34 24872331 Chip, 330 ohm, 1/16W RR35 24366392 CF, 3900 ohm RR36 24366392 CF, 3900 ohm RR37 24366392 CF, 3900 ohm RR40 24366102 CF, 1k ohm RR41 24366332 CF, 3300 ohm RR48 24366222 CF, 2200 ohm RR62 24366102 CF, 1k ohm RR63 24366332 CF, 3300 ohm RR64 24366152 CF, 1500 ohm RR65 24366102 CF, 1k ohm RR66 24366101 CF, 100 ohm RR67 24366271 CF, 270 ohm RR68 24366332 CF, 3300 ohm RR69 24366152 CF, 1500 ohm RR70 24366102 CF, 1k ohm RR71 24366332 CF, 3300 ohm RR72 24366332 CF, 3300 ohm RR73 24366332 CF, 3300 ohm RR81 24366271 CF, 270 ohm RR82 24366101 CF, 100 ohm RR83 24366271 CF, 270 ohm RR84 24366101 CF, 100 ohm RR85 24366102 CF, 1k ohm RR86 24366152 CF, 1500 ohm RR87 24366332 CF, 3300 ohm RR88 24366101 CF, 100 ohm RR99 24366473 CF, 47k ohm RS01 24872681 Chip, 680 ohm, 1/16W RS02 24872681 Chip, 680 ohm, 1/16W RS03 24872101 Chip, 100 ohm, 1/16W RS04 24872101 Chip, 100 ohm, 1/16W RS05 24872472 Chip, 4700 ohm, 1/16W RS06 24872472 Chip, 4700 ohm, 1/16W RS07 24872472 Chip, 4700 ohm, 1/16W RS08 24872472 Chip, 4700 ohm, 1/16W RS09 24872472 Chip, 4700 ohm, 1/16W RS10 24872472 Chip, 4700 ohm, 1/16W RS13 24872101 Chip, 100 ohm, 1/16W RS14 24872101 Chip, 100 ohm, 1/16W RS15 24872104 Chip, 100k ohm, 1/16W RS16 24872104 Chip, 100k ohm, 1/16W RS17 24872223 Chip, 22k ohm, 1/16W RS18 24872223 Chip, 22k ohm, 1/16W

– 50 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description RS19 24872681 Chip, 680 ohm, 1/16W RS20 24872681 Chip, 680 ohm, 1/16W RS21 24872222 Chip, 2200 ohm, 1/16W RS22 24872222 Chip, 2200 ohm, 1/16W RS23 24872101 Chip, 100 ohm, 1/16W RS24 24872101 Chip, 100 ohm, 1/16W RS27 24872104 Chip, 100k ohm, 1/16W RS28 24872104 Chip, 100k ohm, 1/16W RS29 24872223 Chip, 22k ohm, 1/16W RS30 24872223 Chip, 22k ohm, 1/16W RS31 24872103 Chip, 10k ohm, 1/16W RS32 24872104 Chip, 100k ohm, 1/16W RS35 24872223 Chip, 22k ohm, 1/16W RS36 24872223 Chip, 22k ohm, 1/16W RS37 24872104 Chip, 100k ohm, 1/16W RS38 24872104 Chip, 100k ohm, 1/16W RS43 24872681 Chip, 680 ohm, 1/16W RS44 24872681 Chip, 680 ohm, 1/16W RS56 24872102 Chip, 1k ohm, 1/16W RS57 24872223 Chip, 22k ohm, 1/16W RS58 24872223 Chip, 22k ohm, 1/16W RS59 24872681 Chip, 680 ohm, 1/16W RS60 24872102 Chip, 1k ohm, 1/16W RV01 24872101 Chip, 100 ohm, 1/16W RV02 24872101 Chip, 100 ohm, 1/16W RV03 24872101 Chip, 100 ohm, 1/16W RV04 24872101 Chip, 100 ohm, 1/16W RV05 24872101 Chip, 100 ohm, 1/16W RV06 24872101 Chip, 100 ohm, 1/16W RV07 24872162 Chip, 1600 ohm, 1/16W RV08 24872162 Chip, 1600 ohm, 1/16W RV09 24872101 Chip, 100 ohm, 1/16W RV10 24872101 Chip, 100 ohm, 1/16W RV12 24872681 Chip, 680 ohm, 1/16W RV13 24872681 Chip, 680 ohm, 1/16W RV16 24872271 Chip, 270 ohm, 1/16W RV18 24872123 Chip, 12k ohm, 1/16W RV19 24872101 Chip, 100 ohm, 1/16W RV20 24872101 Chip, 100 ohm, 1/16W RV21 24872151 Chip, 150 ohm, 1/16W RV23 24552101 OMF, 100 ohm, 1/2W RV25 24872101 Chip, 100 ohm, 1/16W RV26 24366181 CF, 180 ohm RV27 24872750 Chip, 75 ohm, 1/16W RV28 24872683 Chip, 68k ohm, 1/16W RV29 24872273 Chip, 27k ohm, 1/16W RV30 24872750 Chip, 75 ohm, 1/16W RV31 24872750 Chip, 75 ohm, 1/16W RV32 24872750 Chip, 75 ohm, 1/16W RV33 24872123 Chip, 12k ohm, 1/16W RV34 24872123 Chip, 12k ohm, 1/16W RV35 24872103 Chip, 10k ohm, 1/16W RV36 24872101 Chip, 100 ohm, 1/16W RV37 24872750 Chip, 75 ohm, 1/16W RV60 24366681 CF, 680 ohm RV60 24872102 Chip, 1k ohm, 1/16W RV61 24366681 CF, 680 ohm RV61 24552101 OMF, 100 ohm, 1/2W RV62 24872101 Chip, 100 ohm, 1/16W RV63 24552151 OMF, 150 ohm, 1/2W RV64 24872750 Chip, 75 ohm, 1/16W RV65 24552101 OMF, 100 ohm, 1/2W RV66 24872101 Chip, 100 ohm, 1/16W RV67 24552151 OMF, 150 ohm, 1/2W RV68 24872750 Chip, 75 ohm, 1/16W RV70 24872101 Chip, 100 ohm, 1/16W RV71 24872472 Chip, 4700 ohm, 1/16W RV73 24872103 Chip, 10k ohm, 1/16W RV74 24872104 Chip, 100k ohm, 1/16W RV78 24872100 Chip, 10 ohm, 1/16W RV79 24872102 Chip, 1k ohm, 1/16W RV80 24872271 Chip, 270 ohm, 1/16W RV81 24872750 Chip, 75 ohm, 1/16W RV82 24872101 Chip, 100 ohm, 1/16W RV85 24872750 Chip, 75 ohm, 1/16W RV86 24872750 Chip, 75 ohm, 1/16W RV87 24872750 Chip, 75 ohm, 1/16W RV89 24872750 Chip, 75 ohm, 1/16W RV90 24872681 Chip, 680 ohm, 1/16W RV91 24872681 Chip, 680 ohm, 1/16W RV92 24872100 Chip, 10 ohm, 1/16W RV93 24872104 Chip, 100k ohm, 1/16W RV94 24872103 Chip, 10k ohm, 1/16W RV95 24872472 Chip, 4700 ohm, 1/16W RV97 24872101 Chip, 100 ohm, 1/16W RV800 24366100 CF, 10 ohm RV801 24366222 CF, 2200 ohm RW02 24366271 CF, 270 ohm RW02 24872563 Chip, 56k ohm, 1/16W RW03 24872393 Chip, 39k ohm, 1/16W RW04 24872560 Chip, 56 ohm, 1/16W RW05 24872102 Chip, 1k ohm, 1/16W RW06 24872151 Chip, 150 ohm, 1/16W RW07 24872222 Chip, 2200 ohm, 1/16W RW08 24872821 Chip, 820 ohm, 1/16W RW09 24366563 CF, 56k ohm RW09 24872560 Chip, 56 ohm, 1/16W RW10 24872152 Chip, 1500 ohm, 1/16W RW11 24872561 Chip, 560 ohm, 1/16W RW12 24872272 Chip, 2700 ohm, 1/16W RW13 24366393 CF, 39k ohm RW13 24872821 Chip, 820 ohm, 1/16W RW14 24552121 OMF, 120 ohm, 1/2W RW14 24872560 Chip, 56 ohm, 1/16W RW15 24366223 CF, 22k ohm RW15 24872152 Chip, 1500 ohm, 1/16W RW16 24366273 CF, 27k ohm RW16 24872561 Chip, 560 ohm, 1/16W RW17 24366333 CF, 33k ohm RW17 24872272 Chip, 2700 ohm, 1/16W RW18 24366101 CF, 100 ohm RW18 24872821 Chip, 820 ohm, 1/16W RW19 24366100 CF, 10 ohm RW20 24366392 CF, 3900 ohm RW20 24872101 Chip, 100 ohm, 1/16W RW21 24872102 Chip, 1k ohm, 1/16W RW22 24366102 CF, 1k ohm RW22 24872101 Chip, 100 ohm, 1/16W RW23 24366471 CF, 470 ohm RW23 24872821 Chip, 820 ohm, 1/16W RW24 24366470 CF, 47 ohm RW24 24872821 Chip, 820 ohm, 1/16W RW25 24366182 CF, 1800 ohm RW25 24872101 Chip, 100 ohm, 1/16W RW26 24872101 Chip, 100 ohm, 1/16W RW27 24872102 Chip, 1k ohm, 1/16W RW28 24872271 Chip, 270 ohm, 1/16W RW29 24872392 Chip, 3900 ohm, 1/16W

– 51 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description RW30 24552100 OMF, 10 ohm, 1/2W RW30 24872152 Chip, 1500 ohm, 1/16W RW31 24552331 OMF, 330 ohm, 1/2W RW31 24872101 Chip, 100 ohm, 1/16W RW32 24366820 CF, 82 ohm RW32 24872101 Chip, 100 ohm, 1/16W RW33 24366683 CF, 68k ohm RW33 24872102 Chip, 1k ohm, 1/16W RW34 24366820 CF, 82 ohm RW34 24872271 Chip, 270 ohm, 1/16W RW35 24366683 CF, 68k ohm RW35 24872392 Chip, 3900 ohm, 1/16W RW36 24366330 CF, 33 ohm RW36 24872152 Chip, 1500 ohm, 1/16W RW37 24366152 CF, 1500 ohm RW37 24872101 Chip, 100 ohm, 1/16W RW38 24366102 CF, 1k ohm RW39 24366152 CF, 1500 ohm RW40 24366330 CF, 33 ohm RW41 24366279 CF, 2.7 ohm RW41 24872101 Chip, 100 ohm, 1/16W RW42 24366279 CF, 2.7 ohm RW42 24872101 Chip, 100 ohm, 1/16W RW43 24554221 OMF, 220 ohm, 2W RW43 24872182 Chip, 1800 ohm, 1/16W RW44 24366122 CF, 1200 ohm RW44 24872181 Chip, 180 ohm, 1/16W RW45 24366122 CF, 1200 ohm RW46 24872101 Chip, 100 ohm, 1/16W RW47 24872222 Chip, 2200 ohm, 1/16W RW60 24000824 Chip, Jumper, 2125 type RW61 24872472 Chip, 4700 ohm, 1/16W RW62 24872622 Chip, 6200 ohm, 1/16W RW63 24872101 Chip, 100 ohm, 1/16W RW64 24872101 Chip, 100 ohm, 1/16W RW65 24872101 Chip, 100 ohm, 1/16W RW66 24872681 Chip, 680 ohm, 1/16W RW67 24872222 Chip, 2200 ohm, 1/16W RW68 24872222 Chip, 2200 ohm, 1/16W RW69 24872222 Chip, 2200 ohm, 1/16W RW70 24872333 Chip, 33k ohm, 1/16W RW71 24872182 Chip, 1800 ohm, 1/16W RW72 24872182 Chip, 1800 ohm, 1/16W RW73 24872103 Chip, 10k ohm, 1/16W RW74 24872332 Chip, 3300 ohm, 1/16W RW76 24872182 Chip, 1800 ohm, 1/16W RW77 24000824 Chip, Jumper, 2125 type RW78 24000824 Chip, Jumper, 2125 type RW79 24000824 Chip, Jumper, 2125 type RW80 24872331 Chip, 330 ohm, 1/16W RW81 24872331 Chip, 330 ohm, 1/16W RW82 24872102 Chip, 1k ohm, 1/16W RW83 24872103 Chip, 10k ohm, 1/16W RW84 24872102 Chip, 1k ohm, 1/16W RW85 24000824 Chip, Jumper, 2125 type RW89 24872102 Chip, 1k ohm, 1/16W RW90 24000824 Chip, Jumper, 2125 type RW91 24872103 Chip, 10k ohm, 1/16W RW92 24872103 Chip, 10k ohm, 1/16W RW93 24872101 Chip, 100 ohm, 1/16W RW94 24872101 Chip, 100 ohm, 1/16W RW95 24872101 Chip, 100 ohm, 1/16W RW96 24872102 Chip, 1k ohm, 1/16W RW100 24872563 Chip, 56k ohm, 1/16W RW101 24872393 Chip, 39k ohm, 1/16W RW102 24872563 Chip, 56k ohm, 1/16W RW103 24872393 Chip, 39k ohm, 1/16W RW104 24872682 Chip, 6800 ohm, 1/16W RW105 24872392 Chip, 3900 ohm, 1/16W RW107 24872103 Chip, 10k ohm, 1/16W RW108 24872333 Chip, 33k ohm, 1/16W RW109 24872103 Chip, 10k ohm, 1/16W RW110 24872333 Chip, 33k ohm, 1/16W RW114 24872563 Chip, 56k ohm, 1/16W RW116 24872222 Chip, 2200 ohm, 1/16W RZ01 24872102 Chip, 1k ohm, 1/16W RZ02 24872102 Chip, 1k ohm, 1/16W RZ03 24872332 Chip, 3300 ohm, 1/16W RZ04 24872102 Chip, 1k ohm, 1/16W RZ05 24872221 Chip, 220 ohm, 1/16W RZ06 24872821 Chip, 820 ohm, 1/16W RZ07 24872101 Chip, 100 ohm, 1/16W RZ08 24872471 Chip, 470 ohm, 1/16W RZ09 24872101 Chip, 100 ohm, 1/16W RZ10 24872222 Chip, 2200 ohm, 1/16W RZ11 24872101 Chip, 100 ohm, 1/16W RZ12 24872102 Chip, 1k ohm, 1/16W RZ13 24872102 Chip, 1k ohm, 1/16W RZ14 24872102 Chip, 1k ohm, 1/16W RZ15 24872102 Chip, 1k ohm, 1/16W RZ17 24872221 Chip, 220 ohm, 1/16W RZ18 24872471 Chip, 470 ohm, 1/16W RZ19 24872102 Chip, 1k ohm, 1/16W RZ20 24872101 Chip, 100 ohm, 1/16W RZ22 24872222 Chip, 2200 ohm, 1/16W RZ29 24872331 Chip, 330 ohm, 1/16W RZ30 24872331 Chip, 330 ohm, 1/16W COILS & TRANSFORMERSCOILS & TRANSFORMERSCOILS & TRANSFORMERSCOILS & TRANSFORMERSCOILS & TRANSFORMERS L101 23221803 Coil, Choke, TLN3040D L200 23289479 Coil, Peaking, TRF44R7AF L201 23289100 Coil, Peaking, TRF4100AF L301 23103859 Coil (Ferrite Bead), TEM2011 L303 23237975 Coil, Peaking, TRF4101AC L333 23238702 Coil, Peaking, TRF4101AJ L400 23289101 Coil, Peaking, TRF4101AF L441 23233977 Coil, Linearity, TLN2203AG L441A 23960136 Adhesive, TSE3843-W L442 23248186 Coil, Choke, TLN3346AD L461 23248115 Coil, Choke, TLN3367D *L462 23231220 Deflection Yoke, TDY707JT(R) *L463 23231220 Deflection Yoke, TDY707JT(R) *L464 23231220 Deflection Yoke, TDY707JT(R) L465 23103880 Coil (Ferrite Bead), TEM2011Y L472 23102441 Magnet, MAG-1094 L473 23102441 Magnet, MAG-1094 L474 23102441 Magnet, MAG-1094 L501 23289100 Coil, Peaking, TRF4100AF L503 23289470 Coil, Peaking, TRF4470AF L510 23238718 Coil, Peaking, TRF4479AJ L512 23103845 Coil, TEM2030AY L513 23103845 Coil, TEM2030AY L676 23103832 Chip (Ferrite Bead), TEM2125M L677 23103832 Chip (Ferrite Bead), TEM2125M L682 23103832 Chip (Ferrite Bead), TEM2125M

– 52 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description L683 23103832 Chip (Ferrite Bead), TEM2125M L684 23289109 Coil, Peaking, TRF41R0AF L685 23289109 Coil, Peaking, TRF41R0AF L701 23238562 Coil, Peaking, TRF4109AJ L702 23238562 Coil, Peaking, TRF4109AJ L707 23238562 Coil, Peaking, TRF4109AJ L708 23238562 Coil, Peaking, TRF4109AJ L709 23238562 Coil, Peaking, TRF4109AJ L710 23238562 Coil, Peaking, TRF4109AJ L711 23238562 Coil, Peaking, TRF4109AJ L712 23238562 Coil, Peaking, TRF4109AJ L713 23238562 Coil, Peaking, TRF4109AJ L714 23238562 Coil, Peaking, TRF4109AJ L719 23232878 Coil, Variable, TRF3503K L720 23289102 Coil, Peaking, TRF4102AJ L721 23237805 Coil, Peaking, TRF4222 L722 23289102 Coil, Peaking, TRF4102AJ L723 23237805 Coil, Peaking, TRF4222 L724 23289102 Coil, Peaking, TRF4102AJ L725 23237805 Coil, Peaking, TRF4222 L726 23289102 Coil, Peaking, TRF4102AJ L727 23237805 Coil, Peaking, TRF4222 L728 23289102 Coil, Peaking, TRF4102AJ L729 23237805 Coil, Peaking, TRF4222 L730 23289102 Coil, Peaking, TRF4102AJ L731 23237805 Coil, Peaking, TRF4222 L737 23289560 Coil, Peaking, TRF4560AF L738 23289560 Coil, Peaking, TRF4560AF L739 23289560 Coil, Peaking, TRF4560AF L740 23289560 Coil, Peaking, TRF4560AF L742 23103866 Chip (Ferrite Bead), TEM2105T L743 23103866 Chip (Ferrite Bead), TEM2105T L744 23103866 Chip (Ferrite Bead), TEM2105T L745 23103866 Chip (Ferrite Bead), TEM2105T L746 23103866 Chip (Ferrite Bead), TEM2105T L747 23103866 Chip (Ferrite Bead), TEM2105T L748 23103866 Chip (Ferrite Bead), TEM2105T L749 23103866 Chip (Ferrite Bead), TEM2105T L801 23248213 Coil, Choke, TLN3481AH L802 23248213 Coil, Choke, TLN3481AH L803 23103859 Coil (Ferrite Bead), TEM2011 L804 23103859 Coil (Ferrite Bead), TEM2011 L853 23248035 Coil, Choke, TLN3278D L854 23248073 Coil, Choke, TLN3299D L855 23248073 Coil, Choke, TLN3299D L856 23248073 Coil, Choke, TLN3299D L857 23248073 Coil, Choke, TLN3299D L858 23103859 Coil (Ferrite Bead), TEM2011 L859 23103859 Coil (Ferrite Bead), TEM2011 L860 23280022 Coil, Peaking, TRF4101AZ L861 23103859 Coil (Ferrite Bead), TEM2011 L862 23248073 Coil, Choke, TLN3299D L863 23103859 Coil (Ferrite Bead), TEM2011 L864 23103859 Coil (Ferrite Bead), TEM2011 L865 23103859 Coil (Ferrite Bead), TEM2011 L866 23248073 Coil, Choke, TLN3299D L867 70211045 Coil, Choke, 0.02mH L868 23103859 Coil (Ferrite Bead), TEM2011 L869 23103859 Coil (Ferrite Bead), TEM2011 L870 23248073 Coil, Choke, TLN3299D L871 23248073 Coil, Choke, TLN3299D L872 23248035 Coil, Choke, TLN3278D L892 23238506 Coil, Peaking, TRF4229AJ L893 23238714 Coil, Peaking, TRF4100AJ L911 23237987 Coil, Peaking, TRF4100AC L961 23289100 Coil, Peaking, TRF4100AF L962 23237991 Coil, Peaking, TRF4479AC L963 23237975 Coil, Peaking, TRF4101AC L6101 23103859 Coil (Ferrite Bead), TEM2011 L7701 23103859 Coil (Ferrite Bead), TEM2011 L7702 23103859 Coil (Ferrite Bead), TEM2011 L7703 23103859 Coil (Ferrite Bead), TEM2011 L7704 23103859 Coil (Ferrite Bead), TEM2011 L7705 23103859 Coil (Ferrite Bead), TEM2011 L7706 23103859 Coil (Ferrite Bead), TEM2011 LA01 23289100 Coil, Peaking, TRF4100AF LC05 23238562 Coil, Peaking, TRF4109AJ LC06 23103859 Coil (Ferrite Bead), TEM2011 LF01 23103775 Coil (Ferrite Bead), TEM2014 LF02 24366100 CF, 10 ohm LF03 24366100 CF, 10 ohm LF04 24366100 CF, 10 ohm LF05 23238506 Coil, Peaking, TRF4229AJ LF06 23238562 Coil, Peaking, TRF4109AJ LF07 23238562 Coil, Peaking, TRF4109AJ LF08 23238714 Coil, Peaking, TRF4100AJ LF09 23238714 Coil, Peaking, TRF4100AJ LF10 23238562 Coil, Peaking, TRF4109AJ LF11 23289109 Coil, Peaking, TRF41R0AF LF12 23289100 Coil, Peaking, TRF4100AF LF13 23289100 Coil, Peaking, TRF4100AF LF17 23289100 Coil, Peaking, TRF4100AF LQ01 23238709 Coil, Peaking, TRF4270AJ LQ02 23237991 Coil, Peaking, TRF4479AC LQ03 23237991 Coil, Peaking, TRF4479AC LQ04 23238718 Coil, Peaking, TRF4479AJ LR01 23289100 Coil, Peaking, TRF4100AF LR01 23289109 Coil, Peaking, TRF41R0AF LR02 23289109 Coil, Peaking, TRF41R0AF LR25 23103845 Coil, TEM2030AY LR26 23103845 Coil, TEM2030AY LS02 23103859 Coil (Ferrite Bead), TEM2011 LS45 23103832 Chip (Ferrite Bead), TEM2125M LS46 23103832 Chip (Ferrite Bead), TEM2125M LV06 23103832 Chip (Ferrite Bead), TEM2125M LV07 23103832 Chip (Ferrite Bead), TEM2125M LV08 23289330 Coil, Peaking, TRF4330AF LV09 23289100 Coil, Peaking, TRF4100AF LV10 23289220 Coil, Peaking, TRF4220AF LV11 23289330 Coil, Peaking, TRF4330AF LV42 23289100 Coil, Peaking, TRF4100AF LV43 23289100 Coil, Peaking, TRF4100AF LV47 23238562 Coil, Peaking, TRF4109AJ LW01 23103806 Chip (Ferrite Bead), TEM2114T LW02 23103806 Chip (Ferrite Bead), TEM2114T LW02 23261974 Coil, Choke, HC5-035 LW03 23103806 Chip (Ferrite Bead), TEM2114T LW04 23103859 Coil (Ferrite Bead), TEM2011 LW04 24000824 Chip Jumper, 2125 Type LW05 23103822 Chip (Ferrite Bead), TEM2117T LW05 23103859 Coil (Ferrite Bead), TEM2011 LW06 23103822 Chip (Ferrite Bead), TEM2117T LW07 23103822 Chip (Ferrite Bead), TEM2117T

– 53 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description LW08 23289100 Coil, Peaking, TRF4100AF LW09 23103822 Chip (Ferrite Bead), TEM2117T LW10 23103806 Chip (Ferrite Bead), TEM2114T LW12 23238718 Coil, Peaking, TRF4479AJ LW13 23238702 Coil, Peaking, TRF4101AJ LW14 23238702 Coil, Peaking, TRF4101AJ LW15 23238718 Coil, Peaking, TRF4479AJ LW16 23238718 Coil, Peaking, TRF4479AJ LW17 23238718 Coil, Peaking, TRF4479AJ LW41 23103806 Chip (Ferrite Bead), TEM2114T LW42 23103806 Chip (Ferrite Bead), TEM2114T LW80 23238562 Coil, Peaking, TRF4109AJ LW81 23238562 Coil, Peaking, TRF4109AJ LZ01 23238710 Coil, Peaking, TRF4220AJ LZ02 23238714 Coil, Peaking, TRF4100AJ LZ03 23238714 Coil, Peaking, TRF4100AJ LZ04 23238708 Coil, Peaking, TRF4330AJ LZ05 23238709 Coil, Peaking, TRF4270AJ LZ08 23238707 Coil, Peaking, TRF4390AJ LZ09 70131060 Baze Filter, ZBF253D-00 LZ10 70131060 Baze Filter, ZBF253D-00 T400 23224364 Transformer, Focus, TLN2168AH T401 23224367 Transformer, Horiz. Drive, TLN1098AH *T461 23236552 Transformer, Flyback, TFB3078BD *T461A 23192917 Anode Cap, TCCP5149 T461B 23960136 Adhesive, TSE3843-W T461Z 23236508 Transformer, Flyback, TFB3078ZD T801 23211670 Line Filter, TRF3164G *T803 23217432 Transformer, Power, TPW1562AZ T804 23217361 Transformer, Choke, TPW2009AZ T805 23217413 Transformer, Choke, TPW2015AZ *T862 23217433 Transformer, Converter, TPW3426AS SEMICONDUCTORSSEMICONDUCTORSSEMICONDUCTORSSEMICONDUCTORSSEMICONDUCTORS Q201 A6335470 Transistor, 2SC2712-Y Q202 A6541130 Transistor, 2SA1162-Y Q203 A6541130 Transistor, 2SA1162-Y Q204 A6541130 Transistor, 2SA1162-Y Q205 A6541130 Transistor, 2SA1162-Y Q261 A6335470 Transistor, 2SC2712-Y Q262 A6541130 Transistor, 2SA1162-Y Q270 A6004040 Transistor, RN1404 Q271 A6004040 Transistor, RN1404 Q272 A6014040 Transistor, RN2404 Q273 A6335470 Transistor, 2SC2712-Y Q281 23904943 IC, MM1111XS Q282 A6534040 Transistor, 2SA1015-Y Q291 A6330069 Transistor, 2CS2482 FA-1 Q295 A6317440 Transistor, 2SC1815-Y Q301 23319787 IC, LA7833S Q301B 70391355 Screw, BITTB3X8 SZN Q302 B0385853 IC, TA1241AN Q330 A6317440 Transistor, 2SC1815-Y Q331 A6534040 Transistor, 2SA1015-Y Q352 A6002030 Transistor, RN1203 Q353 A6002030 Transistor, RN1203 Q354 A6534145 Transistor, 2SA1020-Y(C) Q360 B0350510 IC, TA75558S Q361 23314548 Transistor, 2SC4256 Q370 A6534040 Transistor, 2SA1015-Y Q371 A6534145 Transistor, 2SA1020-Y(C) Q372 A6002030 Transistor, RN1203 Q402 A6330069 Transistor, 2CS2482 FA-1 Q404 A6873777 Transistor, 2SD2553 Q404B 72471082 Screw, BRDT2W3X10 SZN Q420 23314141 Transistor, 2SC3852 Q420B 70391356 Screw, BITTB3X10 SZN Q421 A6317440 Transistor, 2SC1815-Y Q430 23314707 Transistor, 2SD1944, H Q460 A6625365 Transistor, 2SB688-O(BS) Q460B 72471082 Screw, BRDT2W3X10 SZN Q461 A6317440 Transistor, 2SC1815-Y Q462 A6317440 Transistor, 2SC1815-Y Q470 A6317440 Transistor, 2SC1815-Y Q480 23314246 Transistor, 2SC2023 LF-4 Q483 B0345651 IC, TA7508P(J) Q491 A6734590 Transistor, 2SC752(G)TM-Y Q501 B0386208 IC, TA1276AN Q502 A6335470 Transistor, 2SC2712-Y Q503 A6541130 Transistor, 2SA1162-Y Q504 A6335470 Transistor, 2SC2712-Y Q518 A6335470 Transistor, 2SC2712-Y Q601 23318413 IC, LA4282 Q611 A6534040 Transistor, 2SA1015-Y Q612 A6534040 Transistor, 2SA1015-Y Q622 A6317440 Transistor, 2SC1815-Y Q671 B0350000 IC, TA75458P Q681 A6342200 Transistor, 2CS2878-A Q682 A6342200 Transistor, 2CS2878-A Q701 B0588213 IC, T7K64(Z) Q703 23905014 IC, LC78816M Q704 23905014 IC, LC78816M Q705 23905014 IC, LC78816M Q707 B0379550 IC, TA8667P Q709 A6734590 Transistor, 2SC752(G)TM-Y Q710 23314204 Transistor, 2SC2412K, Q Q711 23905666 IC, AT24C1610PC Q712 23905666 IC, AT24C1610PC Q713 23905666 IC, AT24C1610PC Q714 23318977 IC, MC14052BFEL Q715 23319808 IC, M5218AP Q717 23319808 IC, M5218AP Q719 23319808 IC, M5218AP Q751 23905094 IC, STR392-110 Q752 23905094 IC, STR392-110 Q754 23904521 IC, AN7805 Q754B 70391356 Screw, BITTB3X10 SZN Q755 23904525 IC, AN7809 Q755B 70391356 Screw, BITTB3X10 SZN Q756 23318841 IC, AN79M09F Q756B 70391356 Screw, BITTB3X10 SZN Q757 A6317440 Transistor, 2SC1815-Y Q758 A6317440 Transistor, 2SC1815-Y Q759 A6534040 Transistor, 2SA1015-Y Q760 23314141 Transistor, 2SC3852 Q760B 70391356 Screw, BITTB3X10 SZN Q761 A6534040 Transistor, 2SA1015-Y Q762 A6317440 Transistor, 2SC1815-Y Q764 B0487045 IC, TC74HC4049AP Q765 A6317440 Transistor, 2SC1815-Y

– 54 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description Q766 A6317440 Transistor, 2SC1815-Y Q767 B0470188 IC, TC4066BP(N) Q768 A6534040 Transistor, 2SA1015-Y Q769 A6317440 Transistor, 2SC1815-Y Q770 A6534040 Transistor, 2SA1015-Y Q771 A6533730 Transistor, 2SA1012-Y Q771B 23035308 Screw, BTB3X8SZN Q771C 23960136 Adhesive, TSE3843-W Q772 A6534040 Transistor, 2SA1015-Y Q773 A6317440 Transistor, 2SC1815-Y Q801 23906540 IC, STR-Z4267 Q810 23906689 IC, PQ05RR11 Q810B 70391355 Screw, BITTB3X8 SZN Q811 A6002050 Transistor, RN1205 Q812 A6317440 Transistor, 2SC1815-Y Q821 A6002010 Transistor, RN1201 Q831 23319941 IC, SI-3050C Q831B 70391356 Screw, BITTB3X10 SZN Q833 23905977 IC, PQ09RD11 Q833B 70391356 Screw, BITTB3X10 SZN *Q862 A8643112 Photo Coupler, TLP621(GRL-L Q901 A6372621 Transistor, 2SC5360 Q902 A6317440 Transistor, 2SC1815-Y Q911 A6372621 Transistor, 2SC5360 Q913 A6317440 Transistor, 2SC1815-Y Q914 A6321240 Transistor, 2SC2120-Y Q921 A6372621 Transistor, 2SC5360 Q922 A6317440 Transistor, 2SC1815-Y Q961 A6317440 Transistor, 2SC1815-Y Q962 A6509140 Transistor, 2SA562TM-Y Q963 A6317440 Transistor, 2SC1815-Y Q964 A6534040 Transistor, 2SA1015-Y Q965 A6317440 Transistor, 2SC1815-Y Q966 A6534040 Transistor, 2SA1015-Y Q6101 A6317440 Transistor, 2SC1815-Y Q9601 A6534040 Transistor, 2SA1015-Y Q9602 A6534040 Transistor, 2SA1015-Y Q9605 A6317440 Transistor, 2SC1815-Y Q9606 A6534040 Transistor, 2SA1015-Y QA01 23000389 IC, CXP750010-126S QA02 23905666 IC, AT24C1610PC QA03 A6534040 Transistor, 2SA1015-Y QA91 A6317440 Transistor, 2SC1815-Y QA92 A6534040 Transistor, 2SA1015-Y QB01 A6534040 Transistor, 2SA1015-Y QB03 A6002050 Transistor, RN1205 QB03 A6534040 Transistor, 2SA1015-Y QB04 A6534040 Transistor, 2SA1015-Y QB81 A6342200 Transistor, 2CS2878-A QB82 A6342200 Transistor, 2CS2878-A QB83 A6534040 Transistor, 2SA1015-Y QB92 A6317440 Transistor, 2SC1815-Y QB93 A6534040 Transistor, 2SA1015-Y QB94 A6534040 Transistor, 2SA1015-Y QB95 A6534040 Transistor, 2SA1015-Y QB96 A6534040 Transistor, 2SA1015-Y QF01 23000258 IC, SDA5273-3S QF02 23314204 Transistor, 2SC2412K, Q QF03 23314204 Transistor, 2SC2412K, Q QF04 A6734590 Transistor, 2SC752(G)TM-Y QF06 23314204 Transistor, 2SC2412K, Q QF11 23906367 IC, PST9146NL QQ01 B0385755 IC, TA1229N QQ02 B0383881 IC, TA8772AN QQ03 A6335470 Transistor, 2SC2712-Y QQ04 A6335470 Transistor, 2SC2712-Y QR01 23000123 IC, MB90096-192 QR01 B0386235 IC, TA1287P QR03 23114530 Transistor, 2SA933S-Q QR05 A6317440 Transistor, 2SC1815-Y QR21 A6335470 Transistor, 2SC2712-Y QR24 A6335470 Transistor, 2SC2712-Y QR35 A6317440 Transistor, 2SC1815-Y QR36 A6317440 Transistor, 2SC1815-Y QR37 A6534040 Transistor, 2SA1015-Y QR38 A6317440 Transistor, 2SC1815-Y QR39 A6534040 Transistor, 2SA1015-Y QR40 A6317440 Transistor, 2SC1815-Y QR41 A6534040 Transistor, 2SA1015-Y QS01 A6359870 Transistor, 2SC3326-B QS02 A6359870 Transistor, 2SC3326-B QS03 A6335470 Transistor, 2SC2712-Y QS04 A6335470 Transistor, 2SC2712-Y QS05 A6359870 Transistor, 2SC3326-B QS06 A6359870 Transistor, 2SC3326-B QS07 A6014040 Transistor, RN2404 QS08 A6359870 Transistor, 2SC3326-B QS09 A6359870 Transistor, 2SC3326-B QS11 A6359870 Transistor, 2SC3326-B QS12 A6014040 Transistor, RN2404 QV01 B0385650 IC, TA1218N QV02 A6335470 Transistor, 2SC2712-Y QV06 A6541130 Transistor, 2SA1162-Y QV07 A6359870 Transistor, 2SC3326-B QV08 A6335470 Transistor, 2SC2712-Y QV09 23114528 Transistor, 2SC1740S, Q QV10 A6335470 Transistor, 2SC2712-Y QV11 A6335470 Transistor, 2SC2712-Y QV12 23114528 Transistor, 2SC1740S, Q QV14 23114528 Transistor, 2SC1740S, Q QV15 A6359870 Transistor, 2SC3326-B QV800 A6317440 Transistor, 2SC1815-Y QW01 B0410841 IC, TC90A18AF(BH QW02 23905013 IC, TLC29321PW QW03 A6030640 IC, TC7S32F QW04 A6030620 IC, TC7S04F QW05 A6030640 IC, TC7S32F QW06 A6030107 IC, TC7S14F QW06 A6317440 Transistor, 2SC1815-Y QW07 A6030685 IC, TC7S86F QW07 A6734590 Transistor, 2SC752(G)TM-Y QW08 B0485997 IC, TC74HC74AF QW09 A6317440 Transistor, 2SC1815-Y QW10 23314204 Transistor, 2SC2412K, Q QW10 A6534040 Transistor, 2SA1015-Y QW11 23314204 Transistor, 2SC2412K, Q QW12 23314204 Transistor, 2SC2412K, Q QW13 23314204 Transistor, 2SC2412K, Q QW14 23314204 Transistor, 2SC2412K, Q QW15 23314204 Transistor, 2SC2412K, Q QW18 23314204 Transistor, 2SC2412K, Q QW19 A6317440 Transistor, 2SC1815-Y QW20 23314204 Transistor, 2SC2412K, Q QW20 A6317440 Transistor, 2SC1815-Y QW21 23314202 Transistor, 2SA1037K, Q QW22 23314204 Transistor, 2SC2412K, Q QW23 23314202 Transistor, 2SA1037K, Q QW24 23314204 Transistor, 2SC2412K, Q

– 55 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description QW25 23314202 Transistor, 2SA1037K, Q QW30 A6335470 Transistor, 2SC2712-Y QW31 23906295 IC, ?PC29M33HB QW32 A6361770 Transistor, 2SC3437-Y QW40 23314202 Transistor, 2SA1037K, Q QW41 23314202 Transistor, 2SA1037K, Q QW42 23314202 Transistor, 2SA1037K, Q QW43 23314202 Transistor, 2SA1037K, Q QW51 23314701 Transistor, 2SB1186A, E QW52 23314705 Transistor, 2SD1763A, VE QZ01 B0410895 IC, TC90A30AF(BH QZ02 A6335470 Transistor, 2SC2712-Y QZ03 A6541130 Transistor, 2SA1162-Y QZ04 A6541130 Transistor, 2SA1162-Y QZ05 A6541130 Transistor, 2SA1162-Y QZ06 A6541130 Transistor, 2SA1162-Y QZ07 A6541130 Transistor, 2SA1162-Y QZ08 A6335470 Transistor, 2SC2712-Y D101 23316756 Diode, Zener, MTZJ33D D201 23118041 Diode, MA111-(TX) D301 23118479 Diode, BYD33J D302 23118479 Diode, BYD33J D303 23115599 Diode, 1N4148 D308 23118822 Diode, ERB12-02 D309 23118822 Diode, ERB12-02 D312 23115599 Diode, 1N4148 D316 23115599 Diode, 1N4148 D317 23115599 Diode, 1N4148 D331 23115599 Diode, 1N4148 D332 23316794 Diode, SC570ALFE2 D342 23115599 Diode, 1N4148 D351 23115599 Diode, 1N4148 D352 23115599 Diode, 1N4148 D353 23316672 Diode, Zener, MTZJ5.6B D354 23115599 Diode, 1N4148 D360 23316677 Diode, Zener, MTZJ6.8A D370 23316672 Diode, Zener, MTZJ5.6B D371 23115599 Diode, 1N4148 D372 23118479 Diode, BYD33J D401 23316687 Diode, Zener, MTZJ9.1B D406 A7978850 Diode, S5295G D408 23118338 Diode, RU-4AM LF-L1 D421 23118041 Diode, MA111-(TX) D427 23316680 Diode, Zener, MTZJ7.5A D428 23316751 Diode, Zener, MTZJ30C D429 23316725 Diode, Zener, MTZJ15B D430 23316568 Diode, Zener, MA8051-M, TX D431 23316558 Diode, HSM2836C, TL D432 23316568 Diode, Zener, MA8051-M, TX D441 23316688 Diode, Zener, MTZJ9.1C D443 23118338 Diode, RU-4AM LF-L1 D444 23118338 Diode, RU-4AM LF-L1 D448 23118479 Diode, BYD33J D460 A7568480 Diode, TVR1G D461 23316582 Diode, ERC20-06 D461C 23960136 Adhesive, TSE3843-W D462 23115599 Diode, 1N4148 D463 23115599 Diode, 1N4148 D464 23316718 Diode, Zener, MTZJ12A D465 23316718 Diode, Zener, MTZJ12A D467 23118479 Diode, BYD33J D470 23115599 Diode, 1N4148 D471 A7568460 Diode, TVR-1B D474 23316719 Diode, Zener, MTZJ12B D481 23316726 Diode, Zener, MTZJ15C D482 23118479 Diode, BYD33J D483 23316720 Diode, Zener, MTZJ12C D484 23316668 Diode, Zener, MTZJ5.1A D486 23115599 Diode, 1N4148 D487 23118479 Diode, BYD33J D488 23115599 Diode, 1N4148 D489 23316681 Diode, Zener, MTZJ7.5B D503 23115599 Diode, 1N4148 D504 23115599 Diode, 1N4148 D506 23115599 Diode, 1N4148 D601 23115599 Diode, 1N4148 D602 23115599 Diode, 1N4148 D603 23115599 Diode, 1N4148 D604 23115599 Diode, 1N4148 D611 23115599 Diode, 1N4148 D612 23115599 Diode, 1N4148 D613 23115599 Diode, 1N4148 D614 23115599 Diode, 1N4148 D615 23115599 Diode, 1N4148 D635 23115599 Diode, 1N4148 D671 23316739 Diode, Zener, MTZJ22C D701 23118859 Diode, 1SS133 D702 23118859 Diode, 1SS133 D703 23118859 Diode, 1SS133 D704 23118859 Diode, 1SS133 D801 23316962 Diode, S1WBA20 4101 D802 23357041 Diode, LN6SB60-F05 D802B 72471082 Screw, BRDT2W3X10 SZN D803 23316718 Diode, Zener, MTZJ12A D804 23316718 Diode, Zener, MTZJ12A D805 23316686 Diode, Zener, MTZJ9.1A D806 23316747 Diode, Zener, MTZJ27C D809 23316753 Diode, Zener, MTZJ33A D810 23316747 Diode, Zener, MTZJ27C D811 23118057 Diode, AG01A D812 23316688 Diode, Zener, MTZJ9.1C D813 23118060 Diode, AL01Z D814 23316672 Diode, Zener, MTZJ5.6B D816 24000656 Varistor, TNR15G471K D817 23115599 Diode, 1N4148 D818 23115599 Diode, 1N4148 D819 23115599 Diode, 1N4148 D820 23316671 Diode, Zener, MTZJ5.6A D821 23316718 Diode, Zener, MTZJ12A D822 23316662 Diode, Zener, MTZJ4.3A D853 23316813 Diode, EG1 D854 23316813 Diode, EG1 D855 23357215 Diode, D4SBS6 D855B 70391355 Screw, BITTB3X8 SZN D856 23357216 Diode, D4SBL20U D856B 70391355 Screw, BITTB3X8 SZN D857 23115532 Diode, ERB12-01 D858 23115599 Diode, 1N4148 D859 23357214 Diode, D4SBS4 D859B 70391355 Screw, BITTB3X8 SZN D860 23357217 Diode, D4SBL40 D860B 70391355 Screw, BITTB3X8 SZN D862 23115599 Diode, 1N4148 D863 23316553 Diode, 1SS145 D891 23115599 Diode, 1N4148 D892 23316745 Diode, Zener, MTZJ27A D893 23316672 Diode, Zener, MTZJ5.6B D901 23115599 Diode, 1N4148

– 56 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description D902 23115599 Diode, 1N4148 D903 23115599 Diode, 1N4148 D911 23115599 Diode, 1N4148 D912 23115599 Diode, 1N4148 D913 23115599 Diode, 1N4148 D914 23115599 Diode, 1N4148 D915 23115599 Diode, 1N4148 D921 23115599 Diode, 1N4148 D922 23115599 Diode, 1N4148 D924 23115599 Diode, 1N4148 D925 23115599 Diode, 1N4148 D926 23115599 Diode, 1N4148 D965 23115599 Diode, 1N4148 D966 23115599 Diode, 1N4148 D7701 23115599 Diode, 1N4148 D7702 23115532 Diode, ERB12-01 D7703 23316751 Diode, Zener, MTZJ30C D7705 23115599 Diode, 1N4148 D7706 23115599 Diode, 1N4148 D7707 23115599 Diode, 1N4148 D7708 23115599 Diode, 1N4148 D7709 23316675 Diode, Zener, MTZJ6.2B D7710 23316716 Diode, Zener, MTZJ11B D7711 23316716 Diode, Zener, MTZJ11B D7717 23316675 Diode, Zener, MTZJ6.2B D7718 23316675 Diode, Zener, MTZJ6.2B D7719 23316675 Diode, Zener, MTZJ6.2B D7720 23316675 Diode, Zener, MTZJ6.2B D7721 23316675 Diode, Zener, MTZJ6.2B D7722 23316675 Diode, Zener, MTZJ6.2B D7723 23115599 Diode, 1N4148 D7724 23115599 Diode, 1N4148 D7725 23115599 Diode, 1N4148 D8301 23115532 Diode, ERB12-01 D8303 23115532 Diode, ERB12-01 DA01 23115599 Diode, 1N4148 DA43 23115599 Diode, 1N4148 DA44 23115599 Diode, 1N4148 DA45 23115599 Diode, 1N4148 DA46 23115599 Diode, 1N4148 DA420 23115599 Diode, 1N4148 DB01 23358504 Diode (LED), SCL003URC3FX DB02 23358503 Diode (LED), SCL003MC3FX DB03 23358515 Diode (LED), SCL003DC3FXG, Orange DB04 23358503 Diode (LED), SCL003MC3FX DF01 23316654 Diode, Zener, MTZJ3.0A DF02 23115599 Diode, 1N4148 DR01 23115599 Diode, 1N4148 DR02 23115599 Diode, 1N4148 DR02 23316557 Diode, HSM221C, TL DR03 23115599 Diode, 1N4148 DR03 23118351 Diode, Zener, RD4.7M-T1BB2 DR61 23115599 Diode, 1N4148 DR62 23115599 Diode, 1N4148 DR63 23115599 Diode, 1N4148 DR65 23115599 Diode, 1N4148 DV01 23118296 Diode, Zener, RD9.1M-T1BB2 DV02 23118296 Diode, Zener, RD9.1M-T1BB2 DV03 23118296 Diode, Zener, RD9.1M-T1BB2 DV04 23118296 Diode, Zener, RD9.1M-T1BB2 DV05 23118296 Diode, Zener, RD9.1M-T1BB2 DV06 23118296 Diode, Zener, RD9.1M-T1BB2 DV07 23118296 Diode, Zener, RD9.1M-T1BB2 DV10 23316557 Diode, HSM221C, TL DV11 23316557 Diode, HSM221C, TL DV12 23118296 Diode, Zener, RD9.1M-T1BB2 DV14 23118296 Diode, Zener, RD9.1M-T1BB2 DV21 23316557 Diode, HSM221C, TL DW04 23115599 Diode, 1N4148 DW05 23115599 Diode, 1N4148 DW21 23115599 Diode, 1N4148 MISCELLANEOUSMISCELLANEOUSMISCELLANEOUSMISCELLANEOUSMISCELLANEOUS B224 23035412 Screw, BTB 4X12 SZN B230 23037312 Screw, BTBW 3X12 SZN B234 23037312 Screw, BTBW 3X12 SZN B241 23035412 Screw, BTB 4X12 SZN B330 23037312 Screw, BTBW 3X12 SZN BB11A 23903022 Socket, 8P BB11B 23903022 Socket, 8P BB11C 23368627 Plug, 8P BB12A 23903022 Socket, 8P BB12B 23903022 Socket, 8P BB12C 23368627 Plug, 8P BB21A 23903022 Socket, 8P BB21B 23903022 Socket, 8P BB21C 23368627 Plug, 8P BB22A 23903022 Socket, 8P BB22B 23903022 Socket, 8P BB22C 23368627 Plug, 8P E921 23964147 Coolant EG/G TCP E951 23964147 Coolant EG/G TCP E981 23964147 Coolant EG/G TCP *F801 23144507 Fuse, 3.15A, 250V F801A 23165433 Holder, Fuse F801B 23165433 Holder, Fuse *F860 23144869 Fuse, 2.5A, 250V F860A 23165433 Holder, Fuse F860B 23165433 Holder, Fuse *F870 23144867 Fuse, 4.0A, 250V F870A 23165433 Holder, Fuse F870B 23165433 Holder, Fuse G005 23115599 Diode, 1N4148 G023 24327180 MF, 18 ohm, ±1%, 1/4W G510 23289479 Coil, Peaking, TRF44R7AF G527 24567104 PF, 0.1?F G528 24567104 PF, 0.1?F G529 24567104 PF, 0.1?F G602 23238714 Coil, Peaking, TRF4100AJ G603 23238714 Coil, Peaking, TRF4100AJ GC05 23103937 Coil (Ferrite Bead), TEM2004 GC06 23103937 Coil (Ferrite Bead), TEM2004 GC07 23103937 Coil (Ferrite Bead), TEM2004 GJ02 24000824 Chip Jumper, 2125Type GJ03 24000824 Chip Jumper, 2125Type GJ04 24000824 Chip Jumper, 2125Type GJ05 24000824 Chip Jumper, 2125Type GJ06 24000824 Chip Jumper, 2125Type GJ08 24000824 Chip Jumper, 2125Type GJ08 24000824 Chip Jumper, 2125Type GJ09 24000824 Chip Jumper, 2125Type GJ09 24000824 Chip Jumper, 2125Type GJ09 24000824 Chip Jumper, 2125Type GJ26 24000824 Chip Jumper, 2125Type GJ27 24000824 Chip Jumper, 2125Type GJ28 24000824 Chip Jumper, 2125Type GJ61 24000824 Chip Jumper, 2125Type

– 57 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description GJ62 24000824 Chip Jumper, 2125Type GJ78 24000824 Chip Jumper, 2125Type GJ79 24000824 Chip Jumper, 2125Type GJ80 24000824 Chip Jumper, 2125Type GJ81 24000824 Chip Jumper, 2125Type GS01 24000824 Chip Jumper, 2125Type GV05 23103832 Chip (Ferrite Bead), TEM2125M GV07 24000824 Chip Jumper, 2125Type GV08 24000824 Chip Jumper, 2125Type GV11 24000824 Chip Jumper, 2125Type GV13 24872681 Chip, 680 ohm, 1/16W GV14 24000824 Chip Jumper, 2125Type GV15 24000824 Chip Jumper, 2125Type GV17 24000824 Chip Jumper, 2125Type GV38 24000824 Chip Jumper, 2125Type GV39 24000824 Chip Jumper, 2125Type GV40 24000824 Chip Jumper, 2125Type GV41 24872102 Chip, 1k ohm, 1/16W GV97 24872101 Chip, 100 ohm, 1/16W H002 23148352 Module, MPSN11A, NICAM/IGR A-PRO KB01 23904946 Remote Sensor, RPM-676CBR-S P507 23902655 Socket, B-B, 15P P661 23365444 Jack, Earphone P701 23368520 Plug, B-B, 20P P702 23368520 Plug, B-B, 20P P708 23902863 Socket, 20P P709 23902863 Socket, 20P P713 23164787 Plug, 7P P714 23164787 Plug, 7P P715 23164787 Plug, 7P P720 23164786 Plug, 6P *P801 23372012 Power Cord(40PW03B) *P801 23372014 Power Cord(40PW03G) P802 23164965 Plug, 4P P881 23164965 Plug, 4P PF01A 23367724 Plug, B-B,15P PH01 23902604 Socket, 21P PH02 23902604 Socket, 21P PH03 23902604 Socket, 21P PU01 23368634 Plug, 25P PU01A 23903025 Socket, 25P PU02 23368634 Plug, 25P PU02A 23903025 Socket, 25P PV10A 23902863 Socket, 20P PV10B 23368520 Plug, B-B, 20P PV11A 23902863 Socket, 20P PV11B 23368520 Plug, B-B, 20P PW01 23368130 Plug, B-B,10P PW02 23368130 Plug, B-B,10P PW06 23902213 Socket, B-B, 10P PW07 23902213 Socket, B-B, 10P S602 23145412 Switch, Slide, 2C2P *S801 23145434 Switch Power, 2C2P SA01 23145226 Switch, Push, 1C1P SA02 23145226 Switch, Push, 1C1P SA03 23145226 Switch, Push, 1C1P SA04 23145226 Switch, Push, 1C1P SA06 23145226 Switch, Push, 1C1P SA07 23145226 Switch, Push, 1C1P *SR81 23146572 Relay, DC5V, DG5D1-O(M)-2 *V901A 23902019 Socket, CRT, 9P V901R 23004868 Protector Coupling R *V902A 23902019 Socket, CRT, 9P V902G 23004869 Protector Coupling G *V903A 23902019 Socket, CRT, 9P V903B 23004870 Protector Coupling B W661 23351131 Speaker, SPK-1390, 120X120mm, 16 ohm W662 23351131 Speaker, SPK-1390, 120X120mm, 16 ohm X401 23153721 Ceramic Resonator, 503kHz, TCR1023 X501 23153961 Crystal, 3.58MHz X503 23153979 Crystal, 4.43MHz XA01 23153497 Crystal, 16.0 MHz XF01 23153421 Crystal, 20.48MHz XQ01 23153969 Crystal, 4.00MHz XV01 23107519 Ceramic Video Trap, 4.43MHz, TCF1066 *Z410 23110842 Focus Pack, TPA6031 Z410A 23505177 Focus Cable *Z450 24082877 CR Block, TPA5007 Z450A 23504953 Anode Cable Z470 23110845 Focus Pack, TPA6032BH Z702 23103823 Filter, TEM2027D Z703 23103823 Filter, TEM2027D Z704 23103823 Filter, TEM2027D Z705 23103823 Filter, TEM2027D Z706 23103823 Filter, TEM2027D Z707 23103823 Filter, TEM2027D Z711 23103823 Filter, TEM2027D Z712 23103823 Filter, TEM2027D *Z801 23905010 IC, HIC1019 *Z853 23144608 Fuse, 4.0A, DC60V *Z854 23144608 Fuse, 4.0A, DC60V *Z856 23144605 Fuse, 2.0A, DC60V PC BOARD ASSEMBLIESPC BOARD ASSEMBLIESPC BOARD ASSEMBLIESPC BOARD ASSEMBLIESPC BOARD ASSEMBLIES *U901A 23783174 CRT-D R Board, PB8764A-1 (40PW03G) *U901A 23784697 CRT-D R Board, PB8764D-1 (40PW03B) *U901B 23783175 CRT-D G Board, PB8764A-2 (40PW03G) *U901B 23784698 CRT-D G Board, PB8764D-2 (40PW03B) *U901C 23783176 CRT-D B Board, PB8764A-3 (40PW03G) *U901C 23784699 CRT-D B Board, PB8764D-3 (40PW03B) *U901D 23783177 SVM Board, PB8764A-4 (40PW03G) *U901D 23784701 SVM Board, PB8764D-4 (40PW03B) *U902A 23784622 Signal Board, PB9402B (40PW03G) *U902A 23784700 Signal Board, PB9402A (40PW03B) *U903 23784625 ED-WAC Board, PB8892B *U904 23784623 DEF Board, PB9403A *U905 23784626 VCD Board, PB8768G *U906A 23784631 TEXT Board, PB9411A *U907 23784628 D-CONVER Board, PB9405A *U908 23784624 Power Board, PB9404A *U909 23783171 Conver Board, PB8773A

– 58 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS Location No. Part No. Description Location No. Part No. Description *U910 23784627 BACK-T Board, PB8774C *U911A 23784629 FRONT Board, PB9406A-1 *U911B 23784630 RMT Board, PB9406A-3 *U911C 23784643 LED Board, PB9406A-2 PICTURE TUBEPICTURE TUBEPICTURE TUBEPICTURE TUBEPICTURE TUBE *V911R 23588477 Projection Tube CRT R *V912B 23588479 Projection Tube CRT B *V912G 23588478 Projection Tube CRT G TUNERTUNERTUNERTUNERTUNER H001 23321344 Tuner, EGA22LWX1 ACCESSORIESACCESSORIESACCESSORIESACCESSORIESACCESSORIES K902 23306324 Remote Hand Unit, CT-90003 AT03 23588265 Battery Cover Y101E 23563880 Owner’s Manual, English, 40PW03G/40PW03B Y101F 23563881 Owner’s Manual, French, 40PW03G/40PW03B Y101G 23563882 Owner’s Manual, German, 40PW03G/40PW03B Y101I 23563883 Owner’s Manual, Itarian, 40PW03G/40PW03B Y101S 23563884 Owner’s Manual, Spanish, 40PW03G/40PW03B CABINET PARTSCABINET PARTSCABINET PARTSCABINET PARTSCABINET PARTS A102 23527078 Speaker Grille R A103 23527079 Speaker Grille L A125 23560038 Label A201 23549940 Bezel A212 23450231 Control Panel A213 23427812 Door A214 70368125 Push Catch for Door A223 23445386 Button, Power A268 23450237 Front Panel A410 23564155 Label, Model No.(40PW03G) A410 23564212 Label, Model No.(40PW03B) *A420 23549370 Back Cover A424 23411329 Back Board A501 23035412 Screw, BTB4X12SZN A505 72471068 Screw, BIDT2 4X12BZ A508 23035412 Screw, BTB4X12SZN A510 23030815 Screw, PTD #6 X 3/4 A513 23035412 Screw, BTB4X12SZN A514 23030815 Screw, PTD #6 X 3/4 A519 23030815 Screw, PTD #6 X 3/4 A521 23030815 Screw, PTD #6 X 3/4 A529 23037312 Screw, BTBW3X12SZN A533 23030815 Screw, PTD #6 X 3/4 A535 23030815 Screw, PTD #6 X 3/4 A541 23030815 Screw, PTD #6 X 3/4 A543 72471068 Screw, BIDT2 4X12BZ A544 23030815 Screw, PTD #6 X 3/4 A701 23064168 Carton A703 23935998 Packing, Top A710 23935999 Packing, Bottom A721 23541008 Bag A726 23845450 Joint K101 23430512 Delta, DELTA67-A/B K102 23430512 Delta, DELTA67-A/B K103 23430512 Delta, DELTA67-A/B K501 23430744 Fresnel Sheet, SCREEN40KKEL K502 23430632 Fresnel Sheet, SCREEN40KJ-F K503 23430745 Screen Protector, SCR-PRO40AKE K601 23430648 Millor, MIRROR40J

– 59 – – 60 – SIGNAL BOARD PB9402A BOTTOM (FOIL) SIDE P507 H001 R6103 D601 C194C101 C106 H002 BB11B Q601 L101 LC06 C102 Q622 C115 C116 C105 D101 LC05 G603 G602 LC08 LC07 TPM01 TP02 TP01 Q281 C281 C282 R281 R282 Q282 R283 C283 C284 BB12B Q832 D8301 C8301 C8304 R8302 R8301 G605 C8302 D8302 C8305 R8304 R8303 P702A RR69 QR38 QR39 RR68 RR70 RR81 RR82 QR40 QR36 RR65 RR85 RR83 RR87 QR41 QR37 RR67 RR84 QR35 RR62 RR88 RR66 GJ47 P860A P605A C609 C680 C613 Q671 C610 D603 D604 D602 C607 R605 R606 C608 CC16 CC18 CC17CC19 C606 C604 C611 CC39 C602 R604 Q682 R6102 R684 R608 R602 C665 C603 C605 Q681 R683 R607 R601 C601R603 C666 R682 C616 D617 D616 R614 Q611 R611 R610 R661 C661 CC29 C674 CC28 R674 R676 C675 R677 R673C676 R679 R678 C677 D671 R672 C672 R671 C671 P602A LC26 C636R636 C682 Q612 R635 R613 D612R612 D635 R688 D611 D614 D613 Q6101 R6101 P804A P805A PV11A PV10A PV03A PU01A PU02A RR61 CC15 TP46B C696 L606 GJ62 GJ63 GJ61 GJ60 R462D462 DR63 RR73 DR61 RR71 DR62 RR72 Q831 C8307 C183 R680 CC30 R675 GJ46 Q833D8303 C8303 C8306 R8306 R8305 GJ10 QA01 QA02 QR01 XA01 RA31 RA32RA410 RB40 CA24 RB44 RA21 RA106 RA02 CA106 RA37 RA36 CA41 CA42 CA43 RR40 DA420 CA430 CA420 LA01 RR31 RR32 RR33 RR03 CR01 RR04 RR01 CR02 RR02 RA34 QV800 RA75 RA70 RA22 CA19 CA15 RA13 PB12A RA07 RB03 QB03 RA10 RA105 RA59 RA61 CR03 RR22 CA440 RR06 RR05 RA104 RA57 DA44 DA45 DA43 DA46 RA72 RA71 CA68 CR20 CR19 LR02 RR08 RR41 QR05 RR09 RR13 RR11 RR12 RR10 RR23 RR07 QB95 RR15 RR34 RB93 RR36 RA108 CA69 LR01 CR10 CR09 CR18 CR11 RB95 QB96 RB97 QB82 RB81 RB82 QB83 RB84RB83 QB81 RR48 RB96 QB94 QB93 QB92 RB94 RB91 RB90 CB90 RB92 RB98 RA19 RA140 RA20 RA11 RA09 RA08 RA15 RA01 RA03 DA01 QA03 RA150 CA14 RA24 RA120 RA06 RA107 RA14 RB43 RB45 RV800 RV801 RA62 GJ01 GJ02 XA02 RA93 LR07LR05 LR06 DR03 DR02 DR01 RR37 RR35 RR16 RR17 QR03 DR65 LR03 RA91 RA92 QA91 RA310 RA55 RA53 CA109 CA108 CA107 GJ31 GJ51 GJ54 D615 PW06 RA97 D503 D506 R515 RR99 RA96 Q295 R295 C295 GJ82 CC47 D605 D606 PW07 PB11A RA63 111 CC48 RA270 GJ84 R402 R401 Q491R403 R386 R516 D504 R670 AGC VT ADR SCL SDA NC +5V +32V IFOUT+ IFOUT- IFIN+ IFIN- GND +5V VIDEO AGC AFT SW1 SW0 S OUT AUDIO 1 4 B E B E B E B E E B E BE BE B E DS-1107A + + + GND B E A/V 1 2 3 4 E B 1 325 10 30 3340455564 B B B B E E E E B B E E E E E E B B B E B E 1113151718 242627 B B + + E B B E 51 0 14 E B 7 12 E B AA AB ACAD AEAF AGAH AIAJ AKAL AN AOAP AQAR ASAT AUAV AWAX AY 5051 5253 5455 BA BCBD BEBF BGBH BIBJ BL BMBN BOBP BQBR BSBT BUBV BWBX BY 27262524232221201918171615987654321 PB13A C697 C698 12345 78 9 10 34 5 12345 R296 P410A RA98 RA99 QA92 B E GC07 GC06 GC05 C150 GJ84

–61 – – 62 – DEF BOARD PB9403A BOTTOM (FOIL) SIDE R FBC T461 C310 C448 R478 L301R307 C307 Q301 C311 D406 C371 D301 D309 D332 C309 R313 C314 C303 C320 D471 C306 R306 R443 C308 R305 D302 C446 D474 D461 R308 C357 R441 R447 D308 C475 T400 C467 R444 D312 P498 Q370 R371 C313 Q420 L441 R370 C447 D408 R448 C370 R373 R405 R374 D370 R312 L465 R301 R472 C418 C419 D444 Q480 G480 C477 R450 R431 R492 R434 C445 D460 R469 C460 R424 R425 Q421 R426 R427 R428 D427 C420 C471 C481Q470 R484 D470 R481R483 R311 R372 R375 R452 R451 R453 R446 R303 P417 R304 R404 C403 D448 R477 L442 D441 R445 R416 D371 L461 R496 C423 D443 Q404 C444 C440 C443 BB22A BB21A R336 R400 P416 P415 P903A C493 R482 R409 R486 Q487 D487 D486 R417 R438 D354 Q353 R353 D353 R408 G487 C305 Z450 Q360 C361 R361 C362 C360 R360 R362 R363 R364 R365 C363R367 R366 R368 Q361 R356 R357 R354 R369 C364 D360 P401 P402 P403 R391 R392 R390 Z470 P797 BB12A BB11A P414 P418 R101 R352 Q483 C482 C484 D484 C485 R439 R498 R495 R499 R488 C483 R494 R487 R435 D488 R489 R497 R485 D489 R493 R490 D482 D481 D483 GJ43 R491 R436 Q291 R292 R298 R299 R297 R296 R291 R295 Q292 R293 R294 GJ44 P701A D428 G401 P496 D429 GJ16 P704A D401 C494 y g o R327 T401 C416 R411 C413 Q402 R415 R410 C417 C463 R429 Q302 D355 R355 C355 C323 C322 R329 C321 R479 R395 D343 R309 R319 R318 R346 D317 D342 R394 R393 R347 D340 R397Q340 D341 R389 R396 Q341 C340 R398 R345 D315 C319 R330 C316 C318 R341 C468R465 R343 Q461 L303 R316 D303 C315 R315 Q394 R383R317 R314 R384 C344 D316 D351 Q352 Q354 R351 R358 R359 C351 D352 Q460 C317 Q462 C465 R462 D467 R463 C464 C466 R454 R455 R480 R466 D464D465 D463 R461 R460 GJ45 R332 C331 Q330 R333 R331 C330 R334 Q331 D331 R335 Q371 D372 R379R378 Q372 R376 R377 R302 8 9 HV-ADJ EBC E B GND FAIL SAFE TEST D-FOCUS V-OUT C B E R X B C E BE E DS-1107A 12 3 4 5 6 12345 6 123456 NC (R) (G)(B) C E BC SCL SDA H.OUT AFC V-STP 16:9ABL 32V WPD H-GND VD 14:9ABL ABL GND GND HBLK GND 9V-1 18V GND X-RAY 18V GND 125V 125V 125V GND GND GND 12V-2 12V-2 GND PROTECT 200V 200V LVP NC HEATER CRT-P BLK GND 18V SDA SCL AFC PROTECT VD GND 1234567 1234 125V 12V GND C E B E B E B E BE B B E E B E BC E B E BE B E B EE B B R7770 R476 C7780 R388 C388 R464 C372 BEC C C C324 P410B

–63 – – 64 – POWER BOARD PB9404A BOTTOM (FOIL) SIDE CAUTION LIVE AREA DS-1107A C860 C863 C807 R803 P497 P496 D803 Q812 P495 P498 T862 C806 T802T801 C801 P800 F801 C805 D816 C867 D802 P805B C802 C803 C804 D801 P801A T803 T804 SR80 D856 C865 Q811 D804 D814 C808 C809 R801 P804B C810 C813 Q810 P802 C812 R857 R858 Z801 R854 C881 C882 C883 R859 C885 R855 L863 C884 C868 C866 L861 C858 D855 C856 L859 C859 C857 L858 D853 C880 D860 C878 L868 C879 C877 L869 C872 D859 C870 L865 C873 C871 L864 D854 C855 C853 C861 C864 C862 L854 Q873 C887 C888 C875 P860BP803A GJ806 Z853 C869 C876 C874 R851 L860 D857 R862 L862 L866 GJ804 R852 Z854 L867 GJ805 R856 R853 R860 L870 Z856 C886 L871 R816 L801 L802 D858 Q862 F860 R809 C820 D813 D812 C817 C825 C815 C824 R811 C814 L804 C822 R815 C823 R812 R861 D809 R807 Q801 C821 D811 D810 L803 R808 R810 C826 C828 C827 BB22B BB21B D805 R818 D806 C830 D808 D807 C816 C819 C829 R814 R805 R806 L856 L855 L857 C818 GJ807 GJ810 T3.15A L/250V 1 3 5 7 9 11 13 1517 E B 1 2 T2.5A L/250V EB + + 12345 L872 1 234 234 - + C889 F870 D863 D862 C811 R863 C831 36V -18V 18V AUDIO 125V R819 R823 D820 D819 Q821 R822 D821 D822 D818 R820 R821 D817 GJ808 GJ809 B E B802 B801 SR81 BRN BLU B803 B804 B805 B806 R802 GJ811 GJ812 GJ802 GJ801 2346 91 01 11 21 31 41 51 61 7 C892 D891C891 D892 L853 D893 L892 L893 R870 T4A L/250V T805 P881 P882 GJ813 GJ814

–65 – – 66 – BACK/T BOARD PB8774C BOTTOM (FOIL) SIDE QS06 QS05 RS27 RS28 RS30 RS29 RV95 QV08 QV07 RV93 RV92 GV15 RS44 RV19 DS03 DS04 RS04 RS03 DS02DS01 DV05 CV12 DV01 RS05 RS06RV02 RS07 RS02 RS01 RV01 RS37 RS38 QS08 QS09 RS35 RS36 RV03 DV03 RS08 RV07 RV08 DV04 DV02 DV07 DV06 RV34 DV11 DV12 RV06 RV04 RV33 DV10 RS23 QS03 RS21 QS04 RS24 RV35 RV36 QS07 RS31 RS32 QS02 RS18 RS17 QS01 RS20 RS45 CS12 RS15 RS19 RV28 RS10 RS09 RV05 RS22 CV35 RV29 C676 R691 R681 R690 R680 RV12 CV19 RV13 CV17 C675 RV64 CV05 RV32 CV37 RV30 R692 C678 R679 R693 C679 R678 CV18 CV16 CV15 RV90 RV91 CV14 R676 R677 C674 RV27 C673 RV77 RV75 RV49 RV25 CV24 QV09 RV46 QV04 RV48 CV45 QV05 QV03 RV41 RV43RV44 DV09 RV42 RV69 RV81 RV89 RV87 QV02 RV21 RV20 RV68 RV47 CV40 RV71 CS CS CV CV CS + + CV RV16 QV11 LV CS17CS18 CV08 CS CV CS QV01 + + CS CS R G SW R G SW L L G SW CS CS RV37 CS CV31 LV31 CV34 RV31 LV37 CS CV CV66 RV63 LV09 RV61 RV2343 LV CV67 CV25 GC03 LV03 GC04 GC01 LV05 GC CV77 CV+ QV10 RV70 QV06 GV41 RV60 RV45 CV44 LV LV40 CV + GV38 RV85 RV86 GV39 GV40 8 9 RV82 DV14 XV01 RV73 RV74 LV11 CV78 RV80 QR21 CS19 RR20 RR29 RR28 RV84 RV83 QV20QV21 CV21 RV88 CV75 RV98 Q271 Q270 DR03 DR02 Q272 R273 R274 C273 Q273 R277 R245 R276 GJ19 GJ18 GV08 L682 L683 C682 LV07LV06 GV05 GV07 L677 L676 CS13 RS16 RS46 RV79 RV97 CS GS01 LV20 C681 GJ23 GJ22 GJ24 GJ21 BE QV14 B E QV12 GJ11 GV97 RV26 RV62 LV42 CV39 RV76 RV66 RV65 BE P004 CC08 GJ27 GJ28 CV65 PV12B LV01 GJ01 GJ02 41 42 43 44 45 46 47 48 49 CV43 P602B 12345 RS60 QS11 QS12 RS59 CS53 RS58 RS57 RS56 CS52 LS02 S602 P004 S601 P603B P604B L681 L686 L678 L687 L688 L689 123456789 P601 CC01CC02 CC12 CC13 CC32 CC03 CC06 CC05 CC04 R683 R682 R672 R671 R673 CC30 PS01 RS14 RS13 GV17 GS43 CV13 RV09 GV13 RV10 GV11 RV18 QS01 RS45 L RV78 QV15 LV10 RV80 GJ26 CV10 LV04 LZ10 LZ04 CZ30 CZ25 CZ22 CZ03 LZ05 LZ03 CZ08 CZ LZ02 1011+ GJ09 GJ08 CZ17 CZ28CZ26CZ12CZ05 CZ29 CZ23 CZ24 CZ45 CZ19 CZ13 GJ61 GJ62 CZ21 RZ06 RZ02CZ11 RZ01 CZ07 RZ22 RZ19 RZ07 QZ03 QZ06 RZ31 RZ11 QZ02 RZ10 RZ12 RZ14 RZ08 QZ05 RZ13 RZ05 QZ04 RZ09 QZ07 RZ04 RZ17 CZ32 CZ33 CZ09 RZ15 CC41 CC42 CZ16 CZ20 CZ36 R675 CV20 RV94 QZ08CZ35 CZ10 LZ01 RZ03 GJ63 RZ20 DV21 QR24RR24 RR25 RZ29 RZ30 PV10B PV11B CV RV67 GV14 GJ29 L672 L671 L674 L673 DS-1107

– 67 – CONVER BOARD PB8773A BOTTOM (FOIL) SIDE P714 P713 P715 R7725 R7735 R7730 R7707 C7721 R7717 C7729 R7712 C7726 C7736 C7735 R7731 R7736 R7726 R7718 C7730 C7725 C7724 R7710 R7720 R7715 R7716 R7721 R7711 R7777 Q764 R7768 C7733 R7723 C7741 R7733 C7738 R7728 R7713 C7727 R7708 C7722 R7722 C7732 R7732 C7740 R7727 C7737 Q765 R7776 R7775Q766 R7778 Q752 Q751 Q767 P708 L7704 L7705 L7706 L7703 L7702 L7701 P709 D7717 D7718 C7774 R7782 R7765 R7783 C7770 Q768 R7784 R7787 R7785 Q769 R7786 C7771 R7788 Q770 R7789 R7791 R7790 Q760 C7778 D7703 C7777 R7793 Q771 C7773 R7750 R7763 R7751 R7792 Q755 C7753 C7754 D7710 C7751 C7752 C7758 C7757 Q756 C7756 C7755 D7702 R7738 Q754 C7749 C7750C7748 C7747 C7761 D7701 R7742 R7741 Q757 R7743 R7744 R7745 Q758 R7746 Q761 R7757 C7762 R7758 C7775 C7772 R7764 Q762 C7763 R7749 R7747 Q759 C7760 C7767 D7709 R7779 R7780 D7719 C7768 C7776 D7708 D7707 R7773 D7706 D7705 R7767 R7766 C7764 C7769 R7781 D7721 D7720 D7722 C7742 C7743 P702B R7752 R7753 R7754 R7755 P720 Q773 Q772 D7723 D7724 R7706 R7705 C7702 R7704 R7703 R7702 P803B R7771 D7711 C7703 R7772 (GREEN)(BLUE) (V) (V) (V) (R) (G) (B)(B) (H) (H) SDAM SCLM VG NSCV I2CS NC NC YSIN BIN GIN RIN YS B G R VD AG HD DG +5v +5V -9V +9V NC NC NC NSH AG BH GH RH AG BV GV RV E C B E B (H) (V) GND OUT IN GND (+9V) GNDOUT IN (-9V) OUT IN(+5V) E B 1 7 814 GND GND GND (RED) 123456 45678 GND 12CS SCLU SDAU GND GND -18V GND GND GND +18V +35V 5V-1 B E B E 12345678 B E BCE B C E 1 8 SDAU PARA DFAI VGND SCLU B E B E B E BE DS-1107A VD PROTECT SDA SCL AFC GND 12C-S C-MUTE C-YS GND C-B C-R GND C-G (H) 18151 0 GND GND -18V +18V +18V -18V -18V -18V GND -18V-18V -18V -18V (G) (R) P701B B C E C7779 R7794 D7725 B705

– 68 – TEXT BOARD PB9411A BOTTOM (FOIL) SIDE PF01A ICF01 LF06LF07 CF DF01 LF LF01 LF13 52 30 CF09 DF02 XF01CF05 CF08 LF05 LF10 CF03 4 56 7 10 11 12 13 14 15 LF08 LF09 15 20 354045 LF17 CF18 CF17 + + CF04 +5V893 DS-1107 LF02 LF03 LF04 CF11 GJ04 RF06 RF03 RF04 GJ02 CF01 QF05 RF30 RF28 RF29 RF05 RF22RF21 RF38 QF02 CF14 RF24 RF26RF11 QF03 RF20 RF12 RF13 RF08 RF09 RF10 RF35 RF36 RF37 QF07 RF32 RF31 RF33 CF13 GJ03 QF08 RF14 QF06 GJ01 GJ05 RF27 RF02 RF01 CF19 CF06 CF07 RF15 CF12 RF16 + - - - B C C B E C B E EB C C E B C E B C EB +9V CF02 QF04 CF20+ QF11 RF39 DF09 DF08 CC46 CC45 GJ09 GJ08 GJ10 GJ11 RF34 CF15 LF12 LF GJ07 GJ06

– 69 – R-DRIVE BOARD PB8764A-1 BOTTOM (FOIL) SIDE K H H SCREEN C BE RED-DRIVE RED BE 23 4 56789 1 0 1 1 R931 R932 R904 Q901 R903 G003 R902 D903 C902 C903 Q902 D902 R901 C905 R935 P906 P914B R908 C904 R905 R906 C901 V901A P907 P932 L961 R962 R961 R963 D961 D962 R965 R964 R966 L962 Q961 Q962 C964 C963 R975 Q963 R968 R967 Q965 Q964 Q966 R969 R973 R977 R974 R970 R971 R972 R976 B E E B B E E E B B EB C961 C962 R978 DS-1107A D966 D965 R936 D901 R909 D904G002 D970 C923 R9702 G-DRIVE BOARD PB8764A-2 BOTTOM (FOIL) SIDE K H H SCREEN GREEN- DRIVE GREEN B E 123 5 6 7 891 0 123456789 R942 R913 D913 C912 P914A G013 D911 Q913C916 C915 P915A V902A R914 C911 P917 P916 + - DS-1107A R946 P903B R948 Q915 E B L963 R933 R916 123456 89 1 0 G012D9 D972 D973 D971 C917 G011

13 D912

E Q911 R942 PV14B C943 C941 L911 C944 R944 Q914 D915 P912 R943 R945 G908 R9704 R996 R9705 R947 Q917 R9703 R9706 R938 Q918 R940 R9707 R993 Q920 R997 R994 Q919 R995 Q925 + + E C B 1 2 3 4 5 6 E B C E E BC BE B E R998Q926 R999 BE R915 R949 R9708 C930 C914 R918 R911 PV16A B-DRIVE BOARD PB8764A-3 BOTTOM (FOIL) SIDE K H H SCREEN C B E BLUE-DRIVE BLUE B 1 23456 89 1 0 C924 R924 R923 Q921 R951 R952 D925 D926 G023 P915B D924 C922 C921 R953C926 R928 R921 Q922 D922 V903A P926 P927 R926 DS-1107A R957 G022 D921 E Q9606 E R9602 R9603 R9604 R9606 C9602 R9605 Q9605 613 614 Q9602 E B B E R9601 B R925 D924 D974 D927 R9617 C925 R9701 Q9601 B E R9615 G021

– 70 – SVM BOARD PB8764A-4 BOTTOM (FOIL) SIDE FRONT BOARD PB9406A-1 BOTTOM (FOIL) SIDE LED BOARD PB9406A-2 BOTTOM (FOIL) SIDE RMT BOARD PB9406A-3 BOTTOM (FOIL) SIDE DS-1107A CW07 QW09 QW06 QW07 QW10 DW04 DW05 RW43 RW40 RW42 RW14 RW31 RW41 RW30 RW36 RW44 LW02 CW21 CW20 CW13 CW18 CW12 LW05 LW04 CW17 RW22 CW15 CW19 CW04 RW15 RW16 CW22 RW24 RW23 RW17 CW05 RW34 CW16 RW35 RW39 RW33 RW38 RW45 RW37 RW32 CW14 P704B RW02DW21 QW20 CW26 RW13 RW09 QW19 RW20RW19 DW20 QW52QW51 PV16B PW04 PW05 PW03 RW18G005 P496 BE BE B E E B B E E B B E B E C GND Y GND C 123 123 P661 PV40 SA01SA02SA03SA04 SA07SA06 PB13B RA73 RA72 RA71 RA78 RA76 P605B L6101 R690 R688 C6104 C6103 C6102 C6101 P660 RA77 GJ01 GJ02LV49 CV48 LV47 RV61 RV60 CV47 CV46 PV15A P-UPP-DOWNVOL-UPVOL-DNMENU EXIT 123 4 123GND KEY-A KEY-B DS-1107A 987654321 DB03 DB04 DB02 DB01 PB12B QB03 QB04 QB01 RB02 RB10 RB01 RB04 RB07 RB05 RB08 RB11 STAND BYTIMERBILINGUALSTEREO 12345 BE B E B E LED GRN ORN GND DS-1107A 5V-2 PB11 KB01 RB12 RB09 CB01 DS-1107A 1234

– 71 – VCD BOARD PB8768G BOTTOM (FOIL) SIDE X401 X503X501 L400 C431 C404 C504 L501 C503 CR12 CR13 CR14 C510 L503 C206 C509 C204 C205 C203 C515 C514 C508 L502 G510 L507 GJ02 GJ01 L510 LQ03 CQ28 CQ31 CQ34 CQ32 CQ33 CQ35 CQ36 CQ39 CQ38 CQ37 CQ20 CQ24 CQ26 CQ29 CQ23 CQ27 CQ25 CQ19 CQ21 LQ04GJ53 GJ52 GJ30 GJ29 GJ28 GJ27 LR24 LR23 L333 CQ14 CQ13 CQ05 CQ07 CQ08 CQ04 CQ11 CQ09CQ10 LQ01 XQ01 CQ15 LQ02 GJ54 P101 C201 GJ60 CR50 C230 C403 L200 C212 C512 CR08 LR01 CR04 CR05 CR06 CR03 CR02 CR01 PV03 L201 GJ87 GJ86 GJ88 GJ89 QR21 CR23 CR24CR22 CR25 GR23 C232 C229 C555 C556 Q501 L511 QQ02 QQ01 QR01 CR51 C210 C214 LR26 LR25 LR27 PU02 PU01 L508 L509 GJ12 GJ13 GJ14 GJ15 C315 C260 PD50B L505 C538 C536 C534 C537 C522 C535 L504 C533 G528 G527 G529 G432 R432 Q430 C432 L513 L512 GJ04 GJ03 AA AB AC AD AE AF AG AH AI AJ AK AL AM ANAO AP AQ AR AS AT AU AW AX AY BA BB BC BD BE BFBG BH BI BJ BK BL BM BN BO BP BQ BR BS BT BU BV BW BX BY 1630 + + + + ++ 828 37 44 DS-1107 13 23 V/C/D 146 145 144 143 142 141 151 152 9 13 16 +++ C B E C517 C519 R501 C507 C505 R401 C502 R407 R403 C430 R223 C511 C521 R207 R209 R208 D216 D217 D215 D219 D218 D220 Q201 R206 C218 R240 R205 R204 C513 C520 CC10 R517 R524 R523 R516 C554 R521R520 Q504 C525 C524 R522 R509 R508 Q503 R510 C231 R217 R502 R503 R235 CQ42 CQ46 CQ18 CQ12 RQ06 CQ45 RQ05 RQ13 CQ40 CQ17 CQ43 RQ02 RQ20 RQ03 RQ04 CQ03 CQ01 RQ01 CQ02 CQ16 RQ08RQ07 CQ22 RQ12 QQ04 RQ09 RQ11 QQ03 RQ10 Q205 R202R201 C501 R518 Q518 R519 D201 R506 R505 Q502R511 C516 R507 R216 R236 RR71 RR72 RR02 RR03 RR01 GJ70 GJ71 GJ72 GJ73 CR09 RR10 CR07 RR12 GJ74 GJ75 GJ76 GJ77 R229 C215 R231 CQ61 CQ62 CQ63 DR12 RR13 C202 GJ81 GJ80 GJ79 GJ78 RR25 RR21 RR23 RR22 RR29 RR24 CR21 RR27 RR20 RR08 RR09 CR10 Q206 D230 C228 D229 Q202 R210 R213 Q203 Q204 R211 R212 R214 R215 RR04 RR31 RR05 R315 RR30 R364 R360 R365 Q360 RJ02 Q237 Q261 C263 R267 R266 R260 R268 R269 R261 R237 R238 Q262 CQ30 R219 C220C221 C219 R220 R218 GJ92 GJ91 GJ90 Q510 R543 R540 R537 R542 R536 GJ85 GJ83 GJ84 GJ82 R534 C523 R533 Q514 R532 R515 C262 GJ11 R222 R402 C415 R239 GJ09 RR06 RR07 GJ06 R415 R421 GJ10 R224 R225 R226 RR16 RR15 RR17 GJ08 GJ07 D422 D421 R422 R321 R425 D430 D432 D431 CC23 D423 R426 R423 GJ40 GJ41 GJ42 GJ43 GJ44 GJ45 GJ46 GJ47 RR32 RR33 RR34 GR01 R4472 R4464 R4462 C4461 R4463 R4461 Q4460 R4460 RR18 R366 D202 D203 C264 CC42 CC40 Q426 Q427Q428

– 72 – VCD BOARD PB9405A BOTTOM (FOIL) SIDE ELC-4970 VD AG HD DG VCCD VCCA NC NC NC NSH AG BH GH RH AG BV GV RV SDAM SCLM VG NSCV SDAU PARA DFAI VG SCLU I2CS NC NC YSIN BIN GIN RIN YS B G R Q719 Q715 P702 P701 Q713 Q707 L713L711L709 L702 L701 L714 L712 L710 L708 L707 L737 C766 C778 C773 C774 C777 C765 C731 C736 C728 C732 L719 C730 Q709 C719 C798 C7701 C799 C795 D703 D704 D702 D701 L738 L740 L739 C741 C742 C745 C746 C750 C749 L726 L727 L723 L722 L728 L729 L725 C770 L724 C769 L721 C762 L720 C761 L731 L730 C781 C782 Q717 TP701 C721 P703 B 5 8 C711 E Q711 Q712 1 144 5 8 R729 C729 L747 C735 R716 Q710 R725R722 R720 R721 R728 C702 C701 R701 R702 R707 R708 R710 R712 R714 R713R711R709 L742 C716 R715 C715 C714 C727 C724 C725 C726 R727 C720 L743 L745 L746 C739 C740 C743 C744 C747 C748 R741 R737 R742 R744 R740 R739 R738 R743 R736 R735 R746 R745 R753 R754 R752 R747 R749 R748 R751 R750 R756 R755 R763 R764 R762 R757 R759 R758 R761 R760 R778 R782 R783 R779 R780 R781 C767 C775 C763 C771 C779 C783 R786 R787 C756 R718 C722 R717 L744 L748 L749 C718 C717R726 R703 R704R705R706 ED WACK BOARD PB8892B BOTTOM (FOIL) SIDE R-1786 CW82 CW83 CW84 CW85 CW86 CW87 CW88 CW89 CW90 CW91 CW92 CW93 RW81 LW04 LW05 LW06 QW14 RW15 RW10 QW12 RW06 RW11 CW08 CW01 CW03 CW02 RW16 CW09 CW05 RW12 CW06 QW11 QW13 QW15 RW08 RW13 RW18 RW60 LW03 CW32 CW78 CW79 CW36 RW62 RW61 CW34 CW35 CW37 CW39 RW76 RW84 CW52 RW83 LW42 LW10 QW23 QW25 RW29RW35 RW72 CW14 RW22 RW28 RW34QW20 RW27 QW22 RW21 QW24 RW33 RW32 RW26 RW20 QW04 LW41 CW47 RW70 CW48 RW02 RW03 QW10 RW100 RW101 RW14 RW103 RW66 RW23 CW11 RW71CW16 QW21RW25 RW24 RW37 RW36 RW31 RW30 CW73 RW41 CW31 CW69 CW75 CW76 CW77 CW60 QW30 RW74 RW45 CW70 CW74 RW102 RW09 RW87 RW86 CW20 RW39 QW17 RW38 QW16 RW19 CW96 CW97 CW41 CW43 CW45 RW43 RW42 CW51 RW44 PW02 LW81 LW80 LW12 LW14 LW CW07 CW04 CW10 CW30CW50 CW72 LW17 LW16 LW CW28 CW29 QW31 CW17 CW CW42 CW44 QW06 + + RW90 LW08 CW33 CW53 QW05 CW49 RW114 CW61 CW62 CW63 CW18 LW09 RW116 RW73 QW03 CW12 CW15 CW13 RW105 QW18 RW104 RW93 LW18 RW80 RW82 RW89 RW88 CW94 CW95 LW01 CW27 CW80 CW81PW01 CW CW CW CW 12345 CW CW CW CW 12 13 14 15 16 17 18 19 20 CW65

– 73 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS TERMINAL VIEW OF TRANSISTORS 1 2SD2253 (old) 2SC5243 2 2SC3852 2SD1763A 2SC1569 2SC4544 2SA1788 2SA1306 2SA1186A 3 2SC752GTM 2SC2482 2SC2655 2SC4721P 4 2SC752 2SA562TM 2SA1015 2SC1815 2SC2878 2SC1740S 2SC2120 2SA9335 5 2SA1788

6 RN2203

8 ON4409

MODEL : 40PW03G / 40PW03B CAUTION : The international hazard symbols "*" in the schematic diagram and the parts list designate components which have special characteristics important for safety and should be replaced only with types identical to those in the original circuit or specified in the parts list. The mounting position of replacements is to be identical with originals. Before replacing any of these components, read carefully the PRODUCT SAFETY NOTICE on the MANUAL for this model. Do not degrade the safety of the receiver through improper servicing. CBSERVATION OF VOLTAGES AND WAVEFORMS 1. Voltages read with VTVM from point shown to chassis ground, line voltage 220 volts, colour bar signal. Voltages reading may vary ±20%. 2. All waveforms are taken using a wide band oscilloscope and a low capacity probe. 3. Waveforms are taken using a standard colour bar signal. 4. Make sure that CONTRAST and COLOUR controls are in mid position and BRIGHTNESS control is almost in maximum position. Set other controls for best picture. NOTES: 1. D.C. resistance value of a principal transformer is shown in this schematic diagram. These are measured for separated from the circuit. 2. The circuits are subject to change without notice. : Solder links. EXPRESSION VALUE OF RESISTOR, CAPACITOR and INDUCTOR 1. Resistance is shown in ohm, K=1,000, M=1,000,000 2. Unless other wise noted in schematic, all capacitor values less than 1 are expressed in ?F and the values more than 1 in pF. 3. Unless other wise noted in schematic, all inductor values more than 1 are expressed in ?H, and the values less than 1 in H.

CAUTION: The international hazard symbols "*" in the schematic diagram and the parts list designate components which have special characteristics important for safety and should be replaced only with types identical to those in the original circuit or specified in the parts list. The mounting position of replacements is to be identical with originals. Before replacing any of these components, read carefully the PRODUCT SAFETY NOTICE on page 3. Do not degrade the safety of the receiver through improper servicing. SCHEMATIC DIAGRAM MODEL : 40PW03G / 40PW03B CBSERVATION OF VOLTAGES AND WAVEFORMS 1. Voltages read with VTVM from point shown to chassis ground, line voltages 220 volts, colour bar signal. Voltage reading may vary ±20%. 2. All waveforms are taken using a wide band oscilloscope and a low capacity probe. 3. Waveforms are taken using a standard colour bar signal. 4. Make sure that CONTRAST and COLOUR controls are in mid position and BRIGHTNESS control is almost in maximum position. Set other controls for best picture. EXPRESSION VALUE OF RESISTOR, CAPACITOR and INDUCTOR 1. Resistance is shown in ohm, K=1,000, M=1,000,000 2. Unless other wise noted in schematic, all capacitor values less than 1 are expressed in ?F and the values more than 1 in pF. 3. Unless other wise noted in schematic, all inductor values more than 1 are expressed in ?H, and the values less than 1 in H. NOTES: 1. D.C. resistance value of a principal transformer is shown in this schematic diagram. These are measured for separated from the circuit. 2. The circuits are subject to change without notice. : Solder links.

– 75 – GENERAL ADJUSTMENTSSPECIFIC INFORMATIONS CATV X ~ Z+2, S1 ~ S41 X1 ~ X19 Colour system Sound system 4.43NTSC 5.5/6.0/6.5 MHz PAL 60Hz 5.5/6.0/6.5 MHz PAL/SECAM/4.43NTSC/3.58NTSC

14 W + 14 W

• Remote control unit × 1
• Battery (R03, AAA) × 2 Rated voltage Power consumption (at AC 220 V, 50 Hz) Dimensions (Width × Height × Depth) Mass Screen size Television system (Aerial input) Colour system Sound output Accessories Channel coverage Special RF signal System PAL B/G PAL I SECAM L SECAM D/K Channel CCIR UK CCIR OIRT UHF 21 – 69 21 – 69 21 – 69 21 – 69 VHF 2 – 12 1 – 12 963.2 mm × 1119.7 mm × 466 mm 51.0 kg Type 40 AC 230 V, 50/60 Hz 150 W SPECIFICATIONS (Representative : 40PW03G) * Please refer to owner’s manual in detail.

1-1, SHIBAURA 1-CHOME, MINATO-KU, TOKYO 105-8001, JAPAN PRINTED IN U.K Feb., 2000 UK FILE NO. 030-200001 SERVICE MANUAL COLOUR TELEVISION C9PJ Chassis 40PW03G,40PW03B