SD500 ASTRODYNE | Alldatasheet
Document overview
- Manufacturer or author: Provided By ALLDATASHEET.COM(FREE DATASHEET DOWNLOAD SITE)
- PDF pages: 6
Technical content
500W Single Output DC-DC Converter SD500 series WWW.ASTRODYNE.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 DC Input Active Surge Current Limiting Wide 4:1~2:1 DC Input Range Protections: Short circuit / Overload / Over voltage / Over Temperature/ Input Polarity(by fuse) 2000VAC I/O Isolation Forced Air Cooling by Built-In DC Fan with Fan Speed Control Function Output OK Signal Built-In Remote ON-OFF Control Built-In Remote Sense Function Model Number Output Volts Output Amps Min Load DC Volt Adjust Efficiency Over Voltage Protection SINGLE OUTPUT SD500L-12 12 Volts(DC) 40 Amps 0~40Amps 11~15Volt(DC) 86% 16~19Volts(DC) SD500L-24 24 Volts(DC) 21 Amps 0~21Amps 23~30Volt(DC) 88% 30.8~35.2Volts(DC) SD500L-48 48 Volts(DC) 10.5 Amps 0~10.5Amps 46~60Volt(DC) 89% 62~68Volts(DC) SD500H-12 12 Volts(DC) 40 Amps 0~40Amps 11~15Volt(DC) 87% 16~19Volts(DC) SD500H-24 24 Volts(DC) 21 Amps 0~21Amps 23~30Volt(DC) 89% 30.8~35.2Volts(DC) SD500H-48 48 Volts(DC) 10.5 Amps 0~10.5Amps 46~60Volt(DC) 90% 62~68Volts(DC)
500W Single Output DC-DC Converter SD500 series WWW.ASTRODYNE.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 INPUT SPECIFICATIONS Input Voltage Range (Note 3) SD500L-xx: 19~72Volts(DC) SD500H-xx: 72~144Volts(DC) Inrush Current, typ: 60Amps (DC) Input Current FL, typ: SD500L-xx: 24.2Amps/ 19 Volts(DC) 24.8Amps/ 24 Volts(DC) 12Amps/ 48 Volts(DC) SD500H-xx: 8Amps/ 72 Volts(DC) 6Amps/ 96 Volts(DC) Input Current NL, typ: SD500L-xx: 0.2Amps/ 48 Volts(DC) SD500H-xx 0.1Amps/ 96 Volts(DC) Min Load See Selection Chart OUTPUT SPECIFICATIONS Voltage and Current See Selection Chart Line Regulation ±0.5% Load Regulation ±0.5% Voltage Tolerance (Note 2) ±1.0% Ripple/Noise (Note 1) 150mVpk-pk max. Setup, Rise Time 500ms, 50m @ FL Over Voltage Protection See Selection Chart Shut down o/p voltage, re-power Over Current Protection 105 ~ 125% rated output power Constant current limiting, shutdown o/p voltage, re-power Over Temperature 80°C±5°C TSW1 detect on heatsink of power transistor 80°C±5(L-48V,H-24V,H-48V), 85°C±5(L-24V) TSW2 : detect on heatsink of o/p diode. Shutdown o/p voltage auto recov after cool down DC Volt Adjust See Selection Chart GENERAL SPECIFICATIONS Safety IEC60950-1 CB approved by TUV Insulation Resistance ≥ 100MΩ / 500Volts(DC) / 25°C / 70% RH EMI Compliance to EN55022B (CISPR22B) Remote Control Please refer to function manual Output OK Signal Open collector signal low when PSU turns on, max. sink current : 10 mAmps Efficiency See Selection Chart Isolation 2000VAC Input - Output 1500VAC Input - Ground 500VAC Output - Ground EMS (Note 4) Compliance to EN61000-4-2, 3, 4, 6, 8 ENV50204, light Industry Level, Criteria A ENVIRONMENTAL SPECIFICATIONS Oper. Temperature -20°C to +60°C (See Derate Curve) Relative Humidity 20~90% RH non cond Storage Temperature -40°C to +85°C, 10~95% RH Temperature Coefficient ±0.02% / °C (0-50°C) MTBF 196.3 KHrs min,MIL-HDBK-217F(25°C) Vibration 10~500Hz, 2G10min./1cycle, period for 60min. each along X, Y, Z axes PHYSICAL SPECIFICATIONS Size (Millimeters / Inches) 215 x 115 x 50 / 8.46” x 4.53 ” x 1.97 ” Weight 20.46 oz (580g) NOTE 1. Ripple & noise are measured at 20MHz of bandwidth by using a 12” twisted pair-wire terminated with a 0.1uf & 47uf parallel capacitor. 2. Tolerance : includes set up tolerance, line regulation and load regula- tion. 3. Derating may be needed under low input voltages. Please check the derating curve for more details. 4. The Power Supply is considered a component which will be installed into final equipment, The final equipment must be re-confirmed that it still passes EMC directives All specifications are typical at nominal input, full load, and 25°C unless other- wise noted
500W Single Output DC-DC Converter SD500 series WWW.ASTRODYNE.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 Assignment Assignment Hirose HRS DF11-6DS
500W Single Output DC-DC Converter SD500 series WWW.ASTRODYNE.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458
500W Single Output DC-DC Converter SD500 series WWW.ASTRODYNE.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458
500W Single Output DC-DC Converter SD500 series WWW.ASTRODYNE.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458