RSP1000 ASTRODYNE | Alldatasheet
Document overview
- Manufacturer or author: Provided By ALLDATASHEET.COM(FREE DATASHEET DOWNLOAD SITE)
- PDF pages: 7
Technical content
1000W Single Output Power Supply RSP1000 series WWW.ASTRODYNETDI.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 Universal AC input Protections:Short circuit/Over load/Over voltage/Over temperature Built-in active PFC function, PF>0.95 Forced air cooling by built-in DC fan Built-in remote sense function Built-in remote ON-OFF control
1 U low profile of 41mm
AC input active surge current limiting DC OK Signal Output voltage can be trimmed between 40~110% of the rated output voltage High power density 10.7W/cubic inch Active Current sharing up to 4000W (3+1) Built-in 5 Volt/0.5 Amp auxiliary power Model Number Output Volts Output Amps OVP Min Load DC Volt Adjust Efficiency SINGLE OUTPUT RSP1000-12 12 Volts(DC) 60 Amps 13.8 ~ 16.8Volt(DC) 0~60 Amps 10~13.5Volt(DC) 83% RSP1000-15 15 Volts(DC) 50 Amps 17 ~ 20.5Volt(DC) 0~50 Amps 13.5~16.5Volt(DC) 85% RSP1000-24 24 Volts(DC) 40 Amps 27.6 ~ 32.4Volt(DC) 0~40 Amps 20~26.4Volt(DC) 88% RSP1000-27 27 Volts(DC) 37 Amps 31 ~ 36.5Volt(DC) 0~37 Amps 24~30Volt(DC) 88% RSP1000-48 48 Volts(DC) 21 Amps 56.6~ 66.2Volt(DC) 0~21 Amps 43~55Volt(DC) 90%
1000W Single Output Power Supply RSP1000 series WWW.ASTRODYNETDI.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 INPUT SPECIFICATIONS Input Voltage Range (Note 3) 90 ~ 264VAC 127~370 Volts(DC) Frequency Range 47-63 Hz Inrush Current, typ: (cold start) 25Amps/115VAC; 40Amps 230VAC Input Current 12 Amps/115V; 6.0 Amps/230V Leakage current < 2.0 mAmps / 240VAC Min Load See Selection Chart Power Factor @ FL 0.95 / 230V; 0.98 / 115V OUTPUT SPECIFICATIONS Voltage and Current See Selection Chart Line / Load Regulation ±0.5% Voltage Tolerance (Note 2) ±1.0% Ripple/Noise (Note 1) 150mVpk-pk Hold Up Time @ FL 16mS / 230VAC Setup, Rise Time @ FL 300mS, 50mS Over Voltage Protection See Selection Chart Shutdown o/p volage, re-power Over Current Protection 105~125% rated output power Constant current limit,auto recover Over Temperature Protection 85°C ±5°C (TSW2) detected on heatsink of O/P diode; 75°C ±5°C (TSW1) detected on heatsink of power transistor DC Volt Adjust See Selection Chart ENVIRONMENTAL SPECIFICATIONS Oper. Temperature -20°C to +60°C (See Derate Curve) Storage Temperature -40°C to +85°C, 10~95% RH Operating Humidity 20~90% RH non cond Temperature Coefficient ±0.02% / °C (0-50°C) MTBF 35KHrs min,MIL-HDBK-217F(25°C) Vibration 10~500Hz, 2G10min./1cycle, period for 60min. each along X, Y, Z axes PHYSICAL SPECIFICATIONS Size 295 x127 x 41mm (11.61”x5 ”x1.61”) Weight 68.78 oz (1950g) GENERAL SPECIFICATIONS Safety UL60950-1, TUV EN60950-1 Insulation Resistance 100MΩ / 500Volts(DC) EMI (Note 4) Compliance to EN55022 (CISPR22) Harmonic Current Compliance to EN61000-3-2,-3 Efficiency See Selection Chart Isolation 3000VAC Input - Output 1500VAC Input - Ground 500VAC Output - Ground EMS (Note 4) Compliance to ENV50204, EN55024, EN61000-6-2 EN61204-3 light Industry Level, Criteria A Auxiliary power(Aux) 5 Volts @ 0.5 Amps (+5%, -8%) Remote ON/OFF Please see the Function Manual Dc OK Signal Please see the Function Manual Output Voltage Trim 40-110%; Please see Function Manual Current Sharing Please see the Function Manual NOTE 1. Ripple & noise are measured at 20MHz of bandwidth by using a 12” twisted pair-wire terminated with a 0.1uf & 47uf parallel capacitor. 2. Tolerance : includes set up tolerance, line reg and load reg. 3. Derating may be needed under low input voltages. Please check the derating curve for more details. 4. The Power Supply is considered a component. The final equipment should be retested for EMC Directive compliance. All specifications are typical at nominal input, full load, and 25°C unless other- wise noted
1000W Single Output Power Supply RSP1000 series WWW.ASTRODYNETDI.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 4625110015909 100 4020 100 -20 01 02 03 04 05 06 07 0 Ta=25 Assignment FG AC/L AC/N TB1 5.02 direction 721 5.81 277.7 4.52 8.7 21 34.5 295 277.7 4.52 8.76 5.02 951 106 11,127 AssignmentAssignmentAssignment VciDC-OK+S Vca GND CS ON/OFF Vco G-AUX 5V-AUX Terminal CN50 SVR51 PFC FILTER RECTIFIERS PFC CONTROL O.L.P. SHARE CURRENT CURRENT V_TRIM SHARE O.V.P. ON/OFF RECTIFIERS CONTROL ON/OFF FAN LIMITING ACTIVE CURRENT INRUSH CONTROL I/P -V +VRECTIFIERS FILTERSWITCHING POWERRECTIFIERS FILTER EMI PWM CIRCUIT DETECTION POWER AUX (HORIZONT AL)
1000W Single Output Power Supply RSP1000 series WWW.ASTRODYNETDI.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 TB1 LOAD SVR51 CN50-V+V AUXG AUX DC_OK ON/OFF CS CN50 Vco Vci Vca GND GND
Description
11,12 5V-AUX DC_OK CS Vco Vca GND G-AUX ON/OFF Vci utput.
1000W Single Output Power Supply RSP1000 series WWW.ASTRODYNETDI.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 -V+V TB1CN50SVR51 LOAD -S (pin2) (pin1) CN50-V+V TB1SVR51 ON ON OFF OFF TB1 LOAD SVR51C N50 SW -V+V AUXG AUXG AUXG AUX AUX AUX DC_OK DC_OK DC_OK ON/OFF ON/OFF ON/OFF CS CS CS CN50 CN50 CN50 Vco Vco Vco Vci Vci Vci Vca Vca Vca GND GND GND GND GND GND
1000W Single Output Power Supply RSP1000 series WWW.ASTRODYNETDI.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 390 560 open 820 1K2 18K 2K2 4K7 7K5 open 100 110 120 100 Vout Vout Vout OVP 120%(Typ.) OVP 120%(Typ.) Non-Linear80 Non-Linear Non-Linear 105 100 TB1SVR51 -V+V AUXG AUXG AUX AUX DC_OK ON/OFF DC_OK ON/OFF CS CS CN50 CN50 Vco Vco Vci Vci Vca Vca GND GND GND GND CN50 AUXG AUX DC_OK ON/OFF CS CN50 Vco Vci Vca GND GND
1000W Single Output Power Supply RSP1000 series WWW.ASTRODYNETDI.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 ow. +S+S+S+S -S-S-S-S AUXGAUXGAUXGAUXG AUXAUXAUXAUX DC_OKDC_OKDC_OKDC_OK ON/OFFON/OFFON/OFFON/OFF CSCSCSCS VcoVcoVcoVco VciVciVciVci VcaVcaVcaVca GNDGNDGNDGND GNDGNDGNDGND PSU PSU PSU PSU SVR51 SVR51S VR51 SVR51 LOAD CN50 CN50 CN50 CN50TB1 TB1T B1 TB1+V +V +V +V-V -V -V -V 1111 11111111 CN50CN50CN50CN50 CS(pin7) +S(pin1) -S(pin2) 2222 12121212