MAX30101DBEVKIT MAXIM | Alldatasheet

Document overview

  • Manufacturer or author: Provided By ALLDATASHEET.COM(FREE DATASHEET DOWNLOAD SITE)
  • PDF pages: 14

Technical content

Features

  • Real-Time Monitoring
  • Flexible PCB Design
  • USB-Powered
  • On-Board Accelerometer
  • Proven PCB Layout
  • Fully Assembled and Tested
  • Windows® 7-, and Windows 8/8.1-Compatible Software 19-8548; Rev 0; 5/16 Ordering Information appears at end of data sheet. Windows is a registered trademark and registered service mark of Microsoft Corporation. Quick Start Required Equipment
  • MAX30101 accelerometer EV kit (MAX30101DBEVKIT#, USBOSMB#, 10-pin FFC cable, and micro-USB cable included)
  • Windows PC Note: Text in bold refers to items directly from the EV kit software. Text in bold and underlined refers to items from the Windows operating system. Procedure The EV kit is fully assembled and tested. Follow the steps below to verify board operation: 1) Visit www.maximintegrated.com/evkit-software to download the most recent version of the EV kit software, MAX30101EVKitSetupVx.x.ZIP. Save the EV kit software to a temporary folder and uncompress the ZIP file. 2) Open up MAX30101EVKitSetupVx.x.exe and follow the instructions from the pop-up windows. 3) Insert one end of the ribbon cable to the J3 connector of the USBOSMB and the other end of the ribbon cable to the J1 connector of the MAX30101DBEV- KIT. Make sure that both connectors and blue ends of the ribbon cable is facing the user. 4) Connect the USB cable from the PC to the EV kit board. Windows will automatically install all drivers. 5) Open the MAX30101EVKit.exe and verify that the EV kit is connected by observing the status bar at the lower left corner of the GUI. See Figure 1. 6) Press the Start Monitor button. 7) Place your finger in front of the MAX30101 (U4) of the EV kit and observe the Measurement graphs. See Figure 2. Example algorithm 1 and 2 are shown in separate windows (Figure 3 and Figure 4).

Figure 1. MAX30101 EV Kit Main Window

Figure 2. MAX30101 EV Kit Main Window (Sampling Data)

surements, and example algorithms. to enable the desired LEDs at each LED slot. Figure 5. MAX30101 EV Kit Main Window (LED Mode with Green LED)

rate and average, pulse width, and ADC full-scale range. recalculated with each change in peak current. Under Proximity, PILOT_PA is adjustable from 0 to 50mA. changes in ADC data of the X, Y, and/or Z graphs. the product and are not intended for mass production. Here are some significant differences between the two. to algorithm. Heart rate is from average of 3s of data. intended for the on-board MCU. Table 1. Resistor Selection for +VLED

Figure 6. MAX30101 Daughter Board Schematic

Figure 13. USBOSMB Mother Board Schematic

Maxim Integrated │ 11 www.maximintegrated.com Evaluates: MAX30101MAX30101 Evaluation System #Denotes RoHS compliant.

Ordering Information

MAX30101ACCEVKIT# EV Kit IR, RED Figure 16. USBOSMB Mother Board PCB Layout—Solder Side

  • MAX30101 DB EV BOM
  • MAX30101 USBOSMB EV BOM Component Lists MAX30101 Accelerometer EV Kit

Maxim Integrated cannot assume responsibility for use of any circuitry other than circuitry entirely embodied in a Maxim Integrated product. No circuit patent licenses are implied. Maxim Integrated reserves the right to change the circuitry and specifications without notice at any time. Maxim Integrated and the Maxim Integrated logo are trademarks of Maxim Integrated Products, Inc. © 2016 Maxim Integrated Products, Inc. │ 12 Evaluates: MAX30101MAX30101 Evaluation System

Revision History

0 5/16 Initial Release — For pricing, delivery, and ordering information, please contact Maxim Direct at 1-888-629-4642, or visit Maxim Integrated’s website at www.maximintegrated.com.

TITLE: Bill of Materials DATE: 07/17/2015, Rev 0 DESIGN: max30101_db_evkit_a ITEM QTY REF DES MFG PART # MANUFACTURER VALUE DESCRIPTION 1 1 C6 C1608X5R1A106K TDK 10UF CAPACITOR; SMT (0603); CERAMIC CHIP; 10UF; 10V; TOL=10%; MODEL=; TG=‐55 2 2 C7, C16 C1608X5R1E106M080AC; CL10A106MA8NRNC TDK/SAMSUNG ELECTRONICS 10UF CAPACITOR; SMT (0603); CERAMIC CHIP; 10UF; 25V; TOL=20%; TG=‐55 DEGC TO 3 1 C12 C1608C0G1H103J; CGA3E2C0G1H103J080AD TDK 0.01UF CAPACITOR; SMT (0603); CERAMIC CHIP; 0.01UF; 50V; TOL=5%; MODEL=C1608 4 1 C13 UMK107AB7105KA TAIYO YUDEN 1UF CAPACITOR; SMT (0603); CERAMIC CHIP; 1UF; 50V; TOL=10%; TG=‐55 DEGC TO 5 1 C14 C1608X5R1E475K080AC TDK 4.7UF CAPACITOR; SMT (0603); CERAMIC CHIP; 4.7UF; 25V; TOL=10%; MODEL=C 6 1 C15 C0603C104K4RACAUTO KEMET 0.1UF CAPACITOR; SMT (0603); CERAMIC CHIP; 0.1UF; 16V; TOL=10%; TG=‐55 DEGC TO 7 0 DS1, DS4, DSMT660N EPITEX SMT660N DIODE; LED; HIGH PERFORMANCE TOP LED; RED; SMT; VF=2V; IF=0.02A 8 0 DS2, DS5, DSMT880 EPITEX SMT880 DIODE; LED; HIGH PERFORMANCE TOP IR LED; INFRARED; SMT; VF=1.45V; 9 0 DS3, DS6, DSMT525 EPITEX SMT525 DIODE; LED; HIGH PERFORMANCE TOP LED; GREEN; SMT; VF=3.2V; IF=0.02A 10 1 J1 68711014522 WURTH ELECTRONICS INC. 68711014522 CONNECTOR; FEMALE; SMT; 0.5MM ZIF HORIZONTAL BOTTOM CONTACT WR‐ 11 0 R1 RC0805JR ‐070RL YAGEO PHYCOMP 0 RESISTOR; 0805; 0 OHM; 5%; JUMPER; 0.125W; THICK FILM 12 3 R2, R12, R1CRCW06030000ZS; MCR03EZPJ000; ERJ‐3GEY0R00 VISHAY DALE/ROHM/PANASONIC 0 RESISTOR; 0603; 0 OHM; 0%; JUMPER; 0.10W; THICK FILM 13 1 U4 MAX30102EFD+ MAXIM MAX30102EFD+ IC; SNSR; PULSE OXIMETER; HEART RATE AND UV SENSOR MODULE FOR MOBILE 14 1 U6 LIS2DH ST MICROELECTRONICS LIS2DH IC; MEMS; MEMS DIGITAL OUTPUT MOTION SENSOR; ULTRA LOW‐POWER HIGH 15 1 U7 MAX8510EXK33+ MAXIM MAX8510EXK33+ IC; VREG; ULTRA‐LOW‐NOISE; HIGH PSRR; LOW‐DROPOUT; 0.12A LINEAR 16 1 EPCB EPCB MAXIM PCB TOTAL 25 PACKOUT (These are DO NOT INSTALL parts and will be shipped with PCB) ITEM QTY REF DES MFG PART # MANUFACTURER VALUE DESCRIPTION 1 1 PACKOUT 88 ‐00713‐LRG N/A ? BOX;+;LARGE BROWN 15 1/8” X 8 3/4" X 3” 2 1 PACKOUT 87 ‐02162‐00 N/A ? ESD BAG;BAG;STATIC SHIELD ZIP 4inX6in;W/ESD LOGO ‐ PACKOUT 3 3 PACKOUT 85 ‐MAXKIT‐PNK N/A ? PINK FOAM;FOAM;ANTI‐STATIC PE 12inX12inX5MM ‐ PACKOUT 4 3 PACKOUT EVINSERT N/A ? WEB INSTRUCTIONS FOR MAXIM DATA SHEET 5 3 PACKOUT 85 ‐84003‐006 N/A ? LABEL(EV KIT BOX) ‐ PACKOUT 6 1 PACKOUT 88 ‐00712‐MDM N/A ? BOX;+;MEDIUM BROWN 9 3/8” X 7 1/4” X 2 1/2" 7 1 PACKOUT 87 ‐02159‐000 N/A ? ESD BAG;+;BAG; STATIC SHIELD 5"X8";W/ESD LOGO 8 1 PACKOUT 88 ‐00711‐SML N/A ? BOX;SMALL BROWN 9 3/16"X7"X1 1/4" ‐ PACKOUT 9 1 PACKOUT 87 ‐02163‐000 N/A ? ESD BAG;+;BAG; STATIC SHIELD ZIP 8”X10”; W/ ESD LOGO TOTAL 15

TITLE: Bill of Materials DATE: 03/27/2015, Rev 0 DESIGN: usbosmb_evkit_a ITEM QTY REF DES MFG PART MANUFACTURER VALUE DESCRIPTION STATUS 1 1 C1 C0603C10 4KEMET 0.1UF CAPACITOR; SMT (0603); CERAMIC CHIP; 0.1UF; 16V; TOL=10%; TG=‐

55 DEGC TO +125 DEGC; TC=X7R AUTO EVKIT‐NOT FOR TEST

2 1 C2 GRM32ER 7MURATA; SAMSUNG ELECTRONICS 10UF CAPACITOR; SMT (1210); CERAMIC CHIP; 10UF; 50V; TOL=10%; TG=‐

55 DEGC TO +125 DEGC; TC=X7R ACTIVE

3 3 C3, C4, C8 UMK107ABTAIYO YUDEN 1UF CAPACITOR; SMT (0603); CERAMIC CHIP; 1UF; 50V; TOL=10%; TG=‐ 4 3 C5, C9, C11C1608X5R1TDK 4.7UF CAPACITOR; SMT (0603); CERAMIC CHIP; 4.7UF; 25V; TOL=10%; MODEL=C SERIES; TG=‐55 DEGC TO +85 DEGC; TC=X5R ACTIVE 5 1 C10 C1608C0G 1TDK; MURATA 0.01UF CAPACITOR; SMT (0603); CERAMIC CHIP; 0.01UF; 50V; TOL=5%; TG=‐

55 DEGC to +125 DEGC; TC=C0G ACTIVE

6 1 DS1 HSMH ‐C19 AVAGO TECHNOLOGIES HSMH‐C190 DIODE; LED; SURFACE MOUNT CHIP LED; RED; SMT (0603); PIV=1.8V; IF=0.02A EVKIT‐NOT FOR TEST 7 1 DS2 HSMG‐C19 AVAGO TECHNOLOGIES HSMG‐C190 DIODE; LED; SURFACE MOUNT CHIP LED; GREEN; SMT (0603); PIV=2.2V; IF=0.02A EVKIT‐NOT FOR TEST 8 1 J1 ZX62RD ‐ABHIROSE ELECTRIC CO LTD. ZX62RD‐AB‐5P8 CONNECTOR; MALE; SMT; MICRO‐USB CONNECTOR MEETING REQUIREMENTS OF USB 2.0 STANDARD; RIGHT ANGLE; 5PINS ACTIVE 9 1 J2 GRPB031V WSULLINS ELECTRONICS CORP. GRPB031VWVN‐RC CONNECTOR; MALE; THROUGH HOLE; 0.050" SINGLE ROW MALE HEADER CONNECTOR; STRAIGHT; 3PINS; ‐40 DEGC TO +105 DEGC EVKIT‐NOT FOR TEST 10 1 J3 6.87E+10 WURTH ELECTRONICS INC. 68711014522 CONNECTOR; FEMALE; SMT; 0.5MM ZIF HORIZONTAL BOTTOM CONTACT WR‐FPC; RIGHT ANGLE; 10PINS EVKIT‐NOT FOR TEST 11 3 R1, R4, R5 ERJ‐2GEJ4 7PANASONIC 470 RESISTOR; 0402; 470 OHM; 5%; 200PPM; 0.10W; THICK FILM EVKIT‐NOT FOR TEST 12 6 R2, R3, R6‐ERJ‐2GEJ47PANASONIC 4.7K RESISTOR; 0402; 4.7K OHM; 5%; 200PPM; 0.10W; THICK FILM EVKIT‐NOT FOR TEST 13 1 R9 CRCW040 2VISHAY DALE 13.7K RESISTOR; 0402; 13.7K OHM; 1%; 100PPM; 0.063W; THICK FILM ACTIVE 14 1 R10 CRCW040 2PANASONIC 36.5K RESISTOR; 0402; 36.5K OHM; 1%; 100PPM; 0.063W; THICK FILM EVKIT‐NOT FOR TEST 15 1 U1 C8051F32 1SILICON LABORATORIES C8051F321 IC; CTRL; FULL SPEED USB, 16K ISP FLASH MCU FAMILY; QFN28‐EP EVKIT‐NOT FOR TEST 16 1 U2 MAX3207 E MAXIM MAX3207EAUT IC; PROT; DUAL, QUAD, AND HEX HIGH‐SPEED DIFFERENTIAL ESD‐ PROTECTION IC; SOT23‐6 ACTIVE 17 1 U3 MAX8510 E MAXIM MAX8510EXK18 IC; VREG; ULTRA‐LOW‐NOISE; HIGH PSRR; LOW‐DROPOUT; 0.12A LINEAR REGULATOR; SC70‐5 ACTIVE 18 1 U5 MAX8512 E MAXIM MAX8512EXK IC, VREG, Ultra‐Low‐Noise, High PSRR, Adjustable Vout, SC70‐5 ACTIVE 19 1 EPCB MAX MAXIM PCB PCB: MAX TOTAL 30 PACK_OUT 1 1 6.88E+11 WURTH ELECTRONICS INC. WR_FFC 0.50mm TYPE 1 CABLE