1N5820 MOTOROLA

Document overview

  • Manufacturer or author: Provided By digicamel.com
  • PDF pages: 6

Technical content

/C0068/C0101/C0115/C0105/C0103/C0110/C0101/C0114/C0039/C0115 /C0068/C0097/C0116/C0097 /C0083/C0104/C0101/C0101/C0116 /C0065/C0120/C0105/C0097/C0108 /C0076/C0101/C0097/C0100 /C0082/C0101/C0099/C0116/C0105/C0102/C0105/C0101/C0114/C0115 . . . employing the Schottky Barrier principle in a large area metal–to–silicon power diode. State–of–the–art geometry features chrome barrier metal, epitaxial construction with oxide passivation and metal overlap contact. Ideally suited for use as rectifiers in low–voltage, high–frequency inverters, free wheeling diodes, and polarity protection diodes.

  • Extremely Low vF
  • Low Power Loss/High Efficiency
  • Low Stored Charge, Majority Carrier Conduction Mechanical Characteristics:
  • Case: Epoxy, Molded
  • Weight: 1.1 gram (approximately)
  • Finish: All External Surfaces Corrosion Resistant and Terminal Leads are Readily Solderable
  • Lead and Mounting Surface Temperature for Soldering Purposes: 220°C Max. for 10 Seconds, 1/16″ from case
  • Shipped in plastic bags, 5,000 per bag
  • Available Tape and Reeled, 1500 per reel, by adding a “RL’’ suffix to the part number
  • Polarity: Cathode indicated by Polarity Band
  • Marking: 1N5820, 1N5821, 1N5822 MAXIMUM RATINGS Rating Symbol 1N5820 1N5821 1N5822 Unit Peak Repetitive Reverse Voltage Working Peak Reverse Voltage DC Blocking Voltage VRRM VRWM VR 20 30 40 V Non–Repetitive Peak Reverse Voltage VRSM 24 36 48 V RMS Reverse Voltage VR(RMS) 14 21 28 V Average Rectified Forward Current (2) VR(equiv) /C0118 0.2 VR(dc), TL = 95°C (RθJA = 28°C/W, P.C. Board Mounting, see Note 2) IO 3.0 A Ambient Temperature Rated VR (dc), PF(AV) = 0 R θJA = 28°C/W TA 90 85 80 °C Non–Repetitive Peak Surge Current (Surge applied at rated load conditions, half wave, single phase

60 Hz, TL = 75°C)

IFSM 80 (for one cycle) A Operating and Storage Junction Temperature Range (Reverse Voltage applied) TJ, Tstg /C004265 to +125 °C Peak Operating Junction Temperature (Forward Current applied) TJ(pk) 150 °C *THERMAL CHARACTERISTICS (Note 2) Characteristic Symbol Max Unit Thermal Resistance, Junction to Ambient R θJA 28 °C/W (1) Pulse Test: Pulse Width = 300 µs, Duty Cycle = 2.0%. (2) Lead Temperature reference is cathode lead 1/32″ from case. * Indicates JEDEC Registered Data for 1N5820–22. Designer’s Data for “Worst Case” Conditions— The Designer’s Data Sheet permits the design of most circuits entirely from the information presented. SOA Limit curves — representing boundaries on device characteristics — are given to facilitate “worst case” design. Preferred devices are Motorola recommended choices for future use and best overall value.  Motorola, Inc. 1996 Order this document by 1N5820/D /C0077/C0079/C0084/C0079/C0082/C0079/C0076/C0065 SEMICONDUCTOR TECHNICAL DATA /C0049/C0078/C0053/C0056/C0050/C0048 /C0049/C0078/C0053/C0056/C0050/C0049 /C0049/C0078/C0053/C0056/C0050/C0050 SCHOTTKY BARRIER RECTIFIERS

3.0 AMPERES

20, 30, 40 VOLTS CASE 267–03 PLASTIC 1N5820 and 1N5822 are Motorola Preferred Devices Rev 2

2 Rectifier Device Data

(1) Pulse Test: Pulse Width = 300 µs, Duty Cycle = 2.0%. (2) Lead Temperature reference is cathode lead 1/32″ from case.

  • Indicates JEDEC Registered Data for 1N5820–22.

reverse power dissipation and thermal runaway into consideration. difference in the rate of change of the slope in the vicinity of 115°C. rectifier circuits and the reverse characteristics of Schottky diodes. Step 4. Find TA(max) from equation (3). Table 1. Values for Factor F *Note that VR(PK) /C0091 2.0 Vin(PK). †Use line to center tap voltage for Vin.

4 Rectifier Device Data

equivalent square power pulse. ΔTJL = the increase in junction temperature above the lead temperature. Figure 5. Thermal Response mocouple placed on the lead as close as possible to the tie point. Figure 6. Forward Power Dissipation 1N5820–22

Figure 7. Typical Forward Voltage Figure 8. Maximum Non–Repetitive Surge Figure 9. Typical Reverse Current Figure 10. Typical Capacitance

1 CYCLE

/C0049/C0078/C0053/C0056/C0050/C0048 /C0049/C0078/C0053/C0056/C0050/C0049 /C0049/C0078/C0053/C0056/C0050/C0050

6 Rectifier Device Data

NOTES: 1. DIMENSIONING AND TOLERANCING PER ANSI Y14.5M, 1982. 2. CONTROLLING DIMENSION: INCH. STYLE 1: PIN 1. CATHODE 2. ANODE K A K D B DIM MIN MAX MIN MAX MILLIMETERSINCHES A 0.370 0.380 9.40 9.65 B 0.190 0.210 4.83 5.33 D 0.048 0.052 1.22 1.32 CASE 267–03 ISSUE C Motorola reserves the right to make changes without further notice to any products herein. Motorola makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does Motorola assume any liability arising out of the application or use of any product or circuit, and specifically disclaims any and all liability, including without limitation consequential or incidental damages. “Typical” parameters which may be provided in Motorola data sheets and/or specifications can and do vary in different applications and actual performance may vary over time. All operating parameters, including “Typicals” must be validated for each customer application by customer’s technical experts. Motorola does not convey any license under its patent rights nor the rights of others. Motorola products are not designed, intended, or authorized for use as components in systems intended for surgical implant into the body, or other applications intended to support or sustain life, or for any other application in which the failure of the Motorola product could create a situation where personal injury or death may occur. Should Buyer purchase or use Motorola products for any such unintended or unauthorized application, Buyer shall indemnify and hold Motorola and its officers, employees, subsidiaries, affiliates, and distributors harmless against all claims, costs, damages, and expenses, and reasonable attorney fees arising out of, directly or indirectly, any claim of personal injury or death associated with such unintended or unauthorized use, even if such claim alleges that Motorola was negligent regarding the design or manufacture of the part. Motorola and are registered trademarks of Motorola, Inc. Motorola, Inc. is an Equal Opportunity/Affirmative Action Employer. Mfax is a trademark of Motorola, Inc. How to reach us: USA / EUROPE / Locations Not Listed: Motorola Literature Distribution;JAPAN : Nippon Motorola Ltd.; Tatsumi–SPD–JLDC, 6F Seibu–Butsuryu–Center, P.O. Box 5405, Denver, Colorado 80217. 303–675–2140 or 1–800–441–2447 3–14–2 Tatsumi Koto–Ku, Tokyo 135, Japan. 81–3–3521–8315 INTERNET : http://Design–NET.com 51 Ting Kok R oad, Tai Po, N.T., Hong Kong. 852–26629298 1N5820/D◊